普罗名特臭氧在线测量仪New_12_10_15_TW_ Ozone_measurement_EN_CN.ppt

E x p e r t s i n C h e m - F e e d a n d W a t e r T r e a t m e n t E x p e r t s i n C h e m - F e e d a n d W a t e r T r e a t m e n t Measuring of Ozone O3 臭氧测量 By amperometric Sensors 电流传感器 By ORP: Oxidation/ Reduction-Potential Sensors氧化还原电位传感器 * With potentiometric ORP-probe RHEP -Au-SE 使用电压传感器RHEP -Au-SE OZE is a selective sensor: only ozone contributes to the signal 臭氧是选择性传感器，只有臭氧才能产生信号 Linear sensitivity in the measuring range : 0.02…2,00 mg/l 灵敏度呈线性，测量范围：0.02…2,00 mg/l temperature: 温度： 4…40°C max. pressure: 最大压力：8 bar calibration:校正 DPD 4 With amperometric sensor type OZE-3 mA 使用电流传感器OZE-3 mA ORP is a generic sensor: all oxidants+reductants contribute to the signal 所有的氧化剂和还原剂都对ORP传感器产生信号 Log. signal/ concentration curve 信号/浓度曲线 High sensitive sensor in the measuring range: 0.000…0.20 mg/l Low sensitive sensor in the measuring range: 0.20 mg/l 0-0.2mg/l 敏感度高，大于0.2mg/l 敏感度低 max. pressure: 8 bar/ max temperature 80°C 最大压力8 bar，最高温度80°C Calbration by standard ORP-buffer solution e.g. 465 mV 使用标准ORP缓冲液校正 Measuring of Ozone 臭氧测量 * good quantification: linear signal curve 线性信号 no cross sensitivity无交叉敏感 reliable control in closed control loops less interferences from water composition 闭环控制稳定，水中物质对其影响较少 more expensive then ORP-measuring only bypass installation价格比ORP贵，只能旁路安装 OZE 3 high sensitive of traces of ozone measurement on/off control possible 低浓度敏感性高，通断控制， cheaper than OZE 比臭氧传感器便宜 in line installation possible 管路安装 no reliable quantification: signal curve is logarithmic cross sensitive towards any other oxidant/ reductant can be interfered by composition of water e.g. pH no reliable control in closed loops 信号非线性，对任何氧化剂，还原剂敏感，受PH值影响，闭环控制不稳定。 RHEP- Au direct measurement ppm O3 measuring ORP (mV) PRO+CONTRA of OZE/ RHEP-AU-Sensors 臭氧与RHEP-AU传感器优缺点对比 * Amperometric Sensor OZE3: Signal Curve OZ3信号曲线 Correlation: [mA]/[ppm] is linear : [mA]/[ppm] 线性 Slope=sensitivity of the method 斜率=灵敏度 Slope o