电机本体设计 永磁同步 ansoft.docVIP

电机本体设计与分析 学院：电气学院 姓名：刘会贵 学号：Z1207009 变频永磁同步电机设计与性能分析 一、路算过程 1、额定参数 2、基本参数 定子数据 定子绕组 定子槽型 转子数据 磁极 添加分析步骤 3、分析结果查看 设计单 ADJUSTABLE-SPEED PERMANENT MAGNET SYNCHRONOUS MOTOR DESIGN File: Setup1.res GENERAL DATA Rated Output Power (kW): 1 Rated Voltage (V): 34 Number of Poles: 4 Frequency (Hz): 2.13333 Frictional Loss (W): 0 Windage Loss (W): 0 Rotor Position: Inner Type of Circuit: Y3 Type of Source: Sine Domain: Time Operating Temperature (C): 75 STATOR DATA Number of Stator Slots: 48 Outer Diameter of Stator (mm): 300 Inner Diameter of Stator (mm): 224 Type of Stator Slot: 2 Stator Slot hs0 (mm): 1 hs1 (mm): 1 hs2 (mm): 20 bs0 (mm): 3 bs1 (mm): 6.92543 bs2 (mm): 9.54717 Top Tooth Width (mm): 8 Bottom Tooth Width (mm): 8 Skew Width (Number of Slots): 0 Length of Stator Core (mm): 150 Stacking Factor of Stator Core: 0.95 Type of Steel: iron Slot Insulation Thickness (mm): 0 Layer Insulation Thickness (mm): 0 End Length Adjustment (mm): 0 Number of Parallel Branches: 2 Number of Conductors per Slot: 18 Type of Coils: 21 Average Coil Pitch: 2 Number of Wires per Conductor: 5 Wire Diameter (mm): 1.024 Wire Wrap Thickness (mm): 0 Slot Area (mm^2): 208.483 Net Slot Area (mm^2): 200.52 Limited Slot Fill Factor (%): 55 Stator Slot Fill Factor (%): 47.0636 Coil Half-Turn Length (mm): 211.45 Wire Resistivity (ohm.mm^2/m): 0.0217 ROTOR DATA Minimum Air Gap (mm): 2 Inner Diameter (mm): 175 Length of Rotor (mm): 150 Stacking Factor of Iron Core: 0.95 Type of Steel: steel_1008 Polar Arc Radius (mm): 110 Mechanical Pole Embrace: 0.9 Electrical Pole Embrace: 0.899105 Max. Thickness of Magnet (mm): 7 Width of Magnet (mm): 150.561 Type of Magnet: NdFe35 Type of Rotor: 1 Magnetic Shaft: Yes PERMANENT MAGNET DATA Residual Flux Density (Tesla): 1.23 Coercive Force (kA/m): 890 Maximum Energy