(2818)--冻结井壁纤维混杂与微膨胀高性能混凝土配制与抗裂试验.pdfVIP

冻结井壁纤维混杂与微膨胀高性能混凝土 配制与抗裂试验 摘 要：为解决深厚表 土层 冻结井壁混凝土开裂渗 漏水难题 ，提出 采 用纤维混杂与微 膨胀 高性 能混凝土。以冻结井壁普通混凝土配合比 为基础 ，采用正交试验法，考察 了水胶 比、膨胀剂掺量、 聚乙烯醇 纤维掺 量及仿钢 纤维掺 量对 纤维混杂与微膨胀 高性能 混凝土的抗压 强度和劈 裂抗拉 强度 的影响 ，综合平衡确定试验的最佳 配合比 为水∶水泥∶NF－F∶膨胀剂∶聚乙烯醇 纤维∶聚 丙烯仿 钢 纤维∶砂 ∶玄武岩碎石＝166．112∶410∶130∶32．8∶1．092∶5∶615．992∶1 095．096 。抗裂试验结果表明 ，纤 维混杂与膨胀剂复合混凝土具有优 良的抗裂性能 。 关键词：井壁混凝土 ；纤维混杂 ；微膨胀 ；最佳 配合比 ；抗裂性能 ；冻结法凿井 ＋ 中图分类号：TD352 ．3 文献标志码：A 文章编号：1003－496X （2020）03－0069-06 Preparation and Crack Resistance Test of High Performance Concrete with Fiber Hybrid and Micro Expansion Freezing Shaft Lining KONG Weihao, YANG Long, YAO Zhishu, XUE Weipei, GAO Cong （School of Civil Engineering and Architecture, Anhui University of Science and Technology, Huainan 232001, China） Abstract: To solve the leakage problem of concrete cracking and seepage in the freezing shaft lining of deep topsoil, it is proposed to use hybrid fibers and micro expansion high -performance concrete. Based on the normal concrete mix ratio of the frozen shaft lining, the orthogonal test method was used to investigate the effect of the water -to -binder ratio, the amount of expansion agent, the amount of polyvinyl alcohol fiber and the amount of imitation steel fiber on the compressive strength and splitting tensile strength of fiber hybrid and micro expansion high performance concrete. Comprehensive balance determines that the best mix ratio of this test is water: cement: NF-F: expansion agent: polyvinyl alcohol fiber: polypropylene imitation steel fiber: sand: basalt gravel =166.112:410:130:32.8:1.092:5:615.992:1 095.096. The crack resistance test results show that the fiber hybrid and expansion agent composite concrete ha