生活垃圾焚烧发电厂掺烧市政污泥的实例分析.pdfVIP

Vol.41 No.6 中国资源综合利用 2023年6月 China Resources Comprehensive Utilization “应用研究 生活垃圾焚烧发电厂掺烧市政污泥的实例分析 张小辉，张朝曦，赵波，宋健 （中节能（南部县）环保能源有限公司，四川南充637300） 摘要：结合生活垃圾楚烧发电厂掺烧市政污泥实例，本文介绍了污泥掺烧方式与掺烧比例等，分别对比研 究了污泥掺烧对锅炉温度、锅炉效率、消石灰用量、SO,排放、飞灰产生量和二嗯英排放的影响。掺烧污泥后， 炉膛温度与锅炉产汽量明显降低，原因为污泥热值低及积灰结焦；烟气指标相近情况下，消石灰单耗增加， 每日消石灰消耗量相较于未掺烧污泥时的消耗量增加10.4%；飞灰产生量基本无变化，二英排放量无明显 变化，毒性当量约为0.02。本研究结果可明确生活垃圾楚烧发电厂掺烧市政污泥的环境影响，指导同行合 理选择污泥掺烧方式。 关键词：市政污泥；生活垃圾；楚烧发电；掺烧 中图分类号：X703 ；TM619 文献标识码：A 文章编号：1008-9500(2023)06-0073-04 D0I:10.3969/j.issn.1008-9500.2023.06.021 Case Analysis on Mixed Combustion of Municipal Sludge in Domestic Waste Incineration Power Plant ZHANG Xiaohui, ZHANG Chaoxi, ZHAO Bo, SONG Jian (CECEP (Nanbu County) Environmental Protection Energy Co., Ltd., Nanchong 637300, China) Abstract: Based on the case of municipal sludge mixed combustion in a domestic waste incineration power plant, this paper introduces the method and proportion of sludge mixed combustion, and compares and studies the effects of sludge mixed combustion on boiler temperature, boiler efficiency, lime consumption, SO2 emissions, fly ash production, and dioxin emissions. After sludge mixed combustion, the furnace temperature and boiler steam production significantly decrease due to the low calorific value of sludge and coking of accumulated ash; when the flue gas indicators are similar, the unit consumption of hydrated lime increases, and the daily consumption of hydrated lime increases by 10.4% compared to the consumption without sludge mixed combustion; the amount of fly ash produced remained basically unchanged, and the amount of dioxin emissions remained unchanged, with a toxicity equivalent of approximately 0.02. The results of this study can clarify t