通信退役电池二次利用关键技术研究.pdfVIP

第2卷第3期 现代工程科技 VoL2 No.3 2023年2月 Modern Engineering Technology Feb.2023 通信退役电池二次利用关键技术研究 张周灿 （中国移动通信集团湖北有限公司黄石分公司，湖北黄石435000） 摘要:在运营商主导的通信行业中，每年都会从机房基站替换下大量蓄电池，将替换电池继续应用于对电池性能要 求较低的场合 ，可有效延长电池的使用寿命 ，缓解环境污染问题 。探讨了不一致性对电池组功效的影响以及判定标 准，提出合理的电池退役筛选机制以及基于超级电容的主动均衡系统 。以电池SOC值作为均衡变量,运用储能电容 式均衡拓扑结构对电池组进行均衡管理 。通过仿真与搭建的测试平台 ，对比电池组在静置与恒流充电两种状态下 SOC值测试情况 。测试结果表明，均衡后的电池组SOC值提升超10%，有效提升了电池利用率 ，降低了运营成本。 关键词:通信退役电池;不一致性:荷电状态:均衡管理 中图分类号:TP29 文献标识码:A Research on Key Technologies of Recycle of Retired Batteries Based on Communication ZHANG Zhoucan (China Mobile Hubei Co., Ltd. Huangshi Branch, Huangshi, Hubei 435000) Abstract: In the communication industry dominated by operators, a large number of batteries are replaced from the base station in the computer room every year, and the replacement batteries will continue to be used in occasions with low requirements on battery performance, which can effectively prolong the service life of batteries and alleviate the environmental pollution problem. This study discusses the influence of inconsistency on the efficiency ofbattery pack and itsjudgment criteria, and puts forward a reasonable battery retirement screening mechanism and an active balancing system based on supercapacitors. Taking the battery SOC value as an equilibrium variable, the energy storage capacitor equilibrium topology is used to balance the management of the battery pack. Through the simulation and built test platform, the SOC value test of battery pack in static state and constant current charging state is compared. The test results show that the SOC