改进的受限空间撞击射流反应器混合效果多尺度模拟Multi-Scale.pdfVIP

改进的受限空间撞击射流反应器混合效果多尺度模拟 1 毕荣山 , 谭心舜, 王振兴, 郑世清 （青岛科技大学计算机与化工研究所，山东 青岛 266042） 摘要：受限空间撞击射流反应器（CIJR）是一种具有高强度混合效果的反应器型式，但其应用受到必须是两股等量物料 进料的限制。本文提出了克服其限制的一种改进的 CIJR 型式，对其在不同进料方式、不同结构尺寸设计原则下获得的 9 种情况的混合性能进行了研究，结果表明：采用大流量组分从顶部进料，小流量组分等分成两股从两侧相对进料的方式可 以获得最优的宏观混合效果；采用三股物流等速度原则设计的结构可以获得最优的微观混合效果；总体混合效果则在采用 小流量分成两股等量从两侧相对进入，大流量组分从顶端进入，而结构尺寸利用三股物流等动量（雷诺数）原则计算的情 况下获得最优效果。本文的研究成果可以为进一步开发多组分、多股进料的CIJR提供基础。 关键词：撞击射流反应器；多尺度；混合；模拟 中图分类号：TQ028 文献标示码：A 文章编号： Multi-Scale Simulation on Mixing Performance of a Kind of Improved Comfined Impinging Jet Reactor Bi Rongshan, Tan Xinshun, Wang Zhenxing, Zheng Shiqing (Research Center for Computers and Chemical Engineering, Qingdao University of Science and Technology, Qingdao City 266042, Shandong Province, China) Abstract: Comfined Impinging jet reactor (CIJR) is a kind of high intensive mixing reactor, but its use is constrained by that there must have two euqal flow rate stream., A kind of improved CIJR was proposed to overcome this shortcoming in this paper. Nine cases on different feed-in methods and configurable scales were studied, and the results showed: The best performance for macro-scale mixing was found on the condition of the component with larger flowrate feed to the reactor from the top, while the component with lower flowrate feed to the reactor from the two sides with opposite direction; The best performance for macro-scale mixing was found on the condition of the velocites of the three feed-in streams were equal; For the whole prcedure of mixing, the The best performanc was found on the condition of the component with larger flowrate feed to the reactor fro