尾巨桉与马占相思PRCAPMP纸浆性能比较研究.pdfVIP

尾巨桉与马占相思木材 P-RC APMP 工艺制浆性能比较 1,2 1 1* 1 1 陈乃明 邓拥军 房桂干 韩善明 焦健 （1.中国林业科学研究院林产化学工业研究所，国家林业局林产化学工程重点开放性实验室，江苏 南京 210042 ； 2. 广西壮族自治区钦州市林业科学研究所，广西 钦州 535000) 摘要：本文以尾巨桉与马占相思为原料，采用 P －RC APMP 工艺对比研究两者的化 学机械法制浆性能。研究结果表明，相同的过氧化氢用量 4.0 ％，氢氧化钠用量3.5 ％ 条件下，两种原料制得纸浆的白度相近均可达 75 ％以上；马占相思原料制浆得率比尾 巨桉约高3 ％左右，物理强度性能远优于尾巨桉浆，相同的250ml 加拿大游离度下， 尾巨桉纸页的抗张强度仅为 20.1N.m/g ，而马占相思纸页的抗张强度可达到26. N·m/g 以上。制得抗张强度相近的纸浆，马占相思比尾巨桉所需的磨浆电耗约低20%左右。 关键词：尾巨桉 马占相思 P-RC APMP Pulping Properties Evaluation on E.urograndis and A mangium Willd Wood Chips Using P-RC APMP Process 1,2 1 1 1 1 CHEN Naiming , DENG Yongjun , HAN Shanming , JIAO Jian ,FANG Guigan * (1.Institute of Chemical Industry of Forest Product, CAF; The Key Laboratory of Forest Chemical Engineering, the state administration of forestry , Nanjing 210042, China;2. Qinzhou Institute of forest,Qinzhou 535000,China) Abstract Pulping properties of E.urograndis and A. mangium Willd wood chips were investigated by using P-RC APMP process. Specific refining energies were recorded and Both physical strength properties and optical properties of pulps were evaluated. Results show that higher brightness of P-RC APMP pulps could be produced from both E.urograndis and A. mangium Willd wood chips and at the chemical dosage level of H2O2 4.0% and NaOH 3.5%, which is very lower chemical consumptions, pulp brightness was able to reach up to 75%ISO; with contrast of pulp yields, that of A mangium Willd wood chips was 3.0 percent points higher than that of E.urograndis wood chips; at the freeness level of 250 ml CSF, Pulps from A mangium Willd wood chips were stronger than that from E.urograndis , for example, The tensile stren