四方面分析如何做好排水管道工程施工质量管理.docVIP

四方面分析如何做好排水管道工程施工质量管理摘　要：从施工准备阶段、管道施工阶段、管线安装、检查井施工以及土方回填和闭水试验等方面论述了市政给排水管道工程施工质量管理重点及措施。 Pick to: based on the construction preparation stage, stage of pipeline construction, pipeline installation and construction inspection Wells and earthwork backfill and closed water test and so on discusses the municipal water supply and drainage pipeline engineering construction quality management emphasis and measures. 关键词：市政；给排水；管道 Key words: municipal; Water supply and drainage; pipeline 　　 一、 施工准备阶段质量控制 A preparation phase, construction quality control 　 （一）道路拆除与恢复? 市政给排水管道施工必然涉及到一定路面的拆除与恢复工作，为了能够保证施工安全及路基质量，在道路开挖前应根据施工图纸计算开口宽度，用白漆标出开挖线之后用切割机将路面切断，用挖掘机对破碎的混凝土路面及碎石等垫层进行开挖并合理堆放以备后用，管路施工完成后的沟槽回填工作直接影响路面的质量及使用功能，尤其是在高原地区更应注重沟槽回填质量，一般对回填土或砂采用夯实或灌水密实，之后采用压路机分层碾压，回填应分层回填及夯实，并应控制每层回填厚度不超过25cm，夯实后采用核子密度仪测量密实度，待其压实率达到95%以上后方可进行下道工序施工。 (a) road demolition and recovery? Municipal water supply and drainage pipeline construction inevitably involves the removal of certain road and back to work, in order to ensure construction safety and quality of roadbed, road excavation shall be computed according to the construction drawings before opening width, marked by white paint after excavation line with cutting machine cutting the pavement, excavator on the broken concrete pavement and gravel cushion layer such as excavation and arrange for later use, after completion of the construction of the pipeline trench backfill work directly affect the quality of the road and use function, more should pay attention to trench backfilling quality especially in plateau area, the general of backfill soil or sand compaction or irrigation is close-grained, after using roller layered crush, backfill should be stratified backfill and compact, and should control each backfill thickness is not more than 25 cm and compactness are measured with nuclear density gauge, after compaction for the compaction rate reaches more than 95% of the rear can construction of next working procedure. 　　 （二）公共设施保护? 管道沟槽施工应根据土质情况