苛性条件下纳米氢氧化铝分散和流变研究.pdfVIP

26 现代化工 July 2006 2006 7 Modern Chemical Industry # 233 # 梁 磊, 郭 奋, 陈建峰 ( 北京化工大学教育部超重力工程研究中心, 北京100029) : , , 0114 g/ mL pH 12, Na CO / NaCl 15% 2173 mol/L , 2 3 (ATH) , Na CO , 2 3 50% ( ) , : ; ; ; :TQ3141255;TB126 :A : 0253 4320( 2006) S1 0233 05 Dispersion and rheology studies on alumina trihydroxide under severe conditions LIANG L ei, GUO Fen, CH EN Jian-f eng (Research Center of the Ministry of Education for High Gravity Engineering and Technology, Beijing University of Chemical Technology, Beijing 100029, China) Abstract: Alumina trihydroxide (ATH) suspension from the carbonation is a very sticky time dependent non Newtonian fluid and its viscosity increases rapidly as the content of ATH raises and becomes intractable when the content of ATH reaches 0114 g/ mL.The rheology and dipersibility of ATH suspension is investigated under severe conditions of pH value above 12, contents of Na CO / NaCl about 15 wt% , ion concentration up to 2173 mol/ L.A rheology method is used to select dispersants 2 3 for the ATH suspension. A concentrated ATH suspension with 50wt% of content is obtained in a solution with pH= 12 and + [Na ] = 21 7 mol/ L, and the viscosity is good. Key words: alumina trihydroxide suspension; severe conditions; dispersant; rheology , , 0114 g/mL 0110 g/ mL 818~ 8 805 mPa#s, 355