600MW超临界直流炉无炉水泵启动和探析.pdfVIP

600MW超临界直流炉无炉水泵启动探析 杨升军 刘武奎，郝润田，冀少峰，曾松柏 （大唐彬长发电有限责任公司陕西 咸阳712000） THE EXPLORATION AND ANALYSIS OF 600 MW SUPER-CRITICAL ONCE-THOROUGH BOILER WITHOUT THE BOILER CIRCULARION WATER PUMP YANG Sheng-jun, LIU Wu-kui, HAO Run-tian , JI Shao-feng, ZENG Song-bo (Datang Binchang power generation Co.,Ltd., Xianyang, China) ABSTRACT: Facing the startup of 600MW super-critical 构架、全悬吊结构∏型直流锅炉。锅炉最大连续 once-thorough boiler in the case of the fault of boiler circulation water pump, the exploration is made. According 蒸发量为2084T/h （B-MCR 工况），额定蒸发量 to the characteristic of start-up of 600MW super-critical 为 1930T/h(BRL 工况) 。锅炉启动系统采用带 once-thorough boiler, the problems is brought out in the case of start-up of without the boiler circulation water pump after 炉水泵的内置式启动系统。由于炉水泵故障又 learning from the manufacturer of boiler and similar 恰逢冷态点炉，单位组织专业组研究相关资 situation of other plant. Accessibility is researched, and succeeded in start-up. The start-up system the program and 料，进行大胆假设、精心论证，并与同类电厂 executing of start-up is introduced in detail. Controlling 及时交流制订无炉水泵启动方案。分析了无炉 points and concerning during the process of start-up is given, further more, the analysis is made that operating work safety 水泵点炉的可行性及面临的问题，并成功实 and economy. It supplies a very important experience for the 施，为同行处理类似事件提供了重要的借鉴经 similar situation. KEY WORD: super-critical; once-thorough boiler; 验。 without the boiler circulation water pump; start-up 2 启动系统介绍 600MW 摘要： 超临界直流炉由于炉水泵故障而面临点炉， 对无炉水泵启动进行了探索。根据超临界直流炉的启动特 启动系统包括两只启动分离器，一台炉水 点，咨询锅炉设备制造厂、以及同类机组的情况，提出了 无炉水泵启动所面临的问题，进行了可行性研究并成功启 泵和一个大气式扩容器以及集水箱疏水系统， 动，并对启动系统、启动方案、实施情况进行了介绍。详 细分析了无炉水泵启动的控制要点及注意事项，并对启动 系