海底隧道锈蚀工字钢与喷射混凝土的粘结滑移试验研究.pdfVIP

第 30 卷第 4 期 Vol.30 No.4 工 程 力 学 2013 年 4 月 Apr. 2013 ENGINEERING MECHANICS 310 文章编号：1000-4750(2013)04-0310-06 海底隧道锈蚀工字钢与喷射混凝土的 粘结滑移试验研究 1 1 2 王明年 ，童建军 ，周国军 (1. 西南交通大学交通隧道工程教育部重点实验室，土木工程学院，成都 610031 ；2. 中国中铁二院工程集团有限责任公司，成都 610031) 摘 要：通过快速电解锈蚀试验，得到不同锈蚀率的工字钢混凝土试件。将这些试件进行粘结滑移试验，描述工 字钢与混凝土的粘结滑移过程，分析锈蚀率、滑移量、粘结破坏荷载之间的关系，建立未锈蚀工字钢与喷射混凝 土的粘结滑移模型，得出粘结滑移影响系数与锈蚀率的回归公式，最终建立锈蚀工字钢与喷射混凝土的粘结滑移 本构关系数学模型。结果表明：随着锈蚀率的增加，滑移量和粘结破坏荷载均降低；未锈蚀工字钢与混凝土的平 均粘结应力是滑移量的四次多项式函数；锈蚀工字钢与混凝土的粘结强度影响系数与锈蚀率的二次多项式函数。 关键词：海底隧道；工字钢；喷射混凝土；锈蚀；粘结滑移；本构关系；试验 中图分类号：TU91 文献标志码：A doi: 10.6052/j.issn.1000-4750.2011.12.0875 TEST RESEARCH ON THE BOND-SLIP BETWEEN I-BEAM AND SHOTCRETE IN UNDERSEA TUNNEL 1 1 2 WANG Ming-nian , TONG Jian-jun , ZHOU Guo-jun (1. Key Laboratory of Transportation Tunnel Engineering, Ministry of Education, School of Civil Engineering, Southwest Jiaotong University, Chengdu 610031, China; 2. China Railway Eryuan Engineering Group Limited Liability Company, Chengdu 610031, China) Abstract: By the accelerated electroanalysis corrosion test, I-beam concrete specimens with different corrosion degrees were obtained. Based on the bond-slip tests with these specimens, the process of bond-slip between I-beam and shotcrete was described, and the relationship between corrosion degree, slippage and bond damage load was analyzed. Then the bond-slip model of an uncorroded I-beam and shotcrete was established, and