肉种鸡夏季通风指导资料.pptVIP

Example – Tunnel Inlet Area 举例 – 纵向进风口面积 Total operating fan capacity = 400 224m3/hr 总的风机通风量=400224立方米/小时 Inlet area = 400 224 ÷ 2 ÷ 3600 = 56m2 进风口面积=400224/2/3600=56平方米 This is the total unrestricted area 这是总的进风口面积 Install ±28m2 per side (minimum) 每侧安装28平方米（最少） Air Deflectors 挡风帘 Air Deflectors Air Deflectors 挡风帘 For houses that do not have enough fan capacity 对于鸡舍没有足够的风机通风量 Air Deflectors increase the air speed through the house 挡风帘能增加鸡舍的风速 They do this by reducing the Cross Section Area that the air travels through 由于减少了鸡舍截面积 Installation: 安装 10-12m apart 10-12米间距 Not less than ±2,2m above the shavings 垫料位置以上至少2.2米高度 Installing them too low can increase the fan negative pressure significantly. 安装太低会明显增加风机工作负压 Maintenance 维护 Proper maintenance is a critical part of ventilating any poultry house during hot weather 夏季鸡舍通风的关键部分是适当的维护 Fans 风机 Pulley’s 皮带轮 Belts 皮带 Shutters must open freely 百叶必须能自由开启 Cooling pads 湿帘 Clean 干净 Unrestricted 没有阻碍物 Light traps 遮黑罩 In good condition 状态良好 Clean from dust 清洁灰尘 New belt 新的皮带 Worn belt – slower fan speed磨损的皮带- 风机转速慢 New cooling pad 新的湿帘 Blocked cooling pad – higher pressure, lower fan capacity, less air speed 湿帘堵塞- 负压高，风机通风量少，风速低 Monitoring Tunnel Ventilation Performance 观察纵向通风效果 Measuring pressure at the fans is a good way to monitor the “condition” of the house and equipment 检查风机的负压是监测鸡舍和设备“状态”的好方法 When the house is new, or pads replaced and fan maintenance done, operate full tunnel v