无溶剂环氧防腐涂料的用途和使用.docVIP

无溶剂环氧防腐涂料Intended Uses 用途 不含挥发性有机溶剂，固体份达100%，室温固化5-45漆膜附着力强，机械性能优，易施工。漆膜耐水性优，由于采用特种固化剂，固化后的漆膜无毒，不污染饮用水和食品。适用于通风不良的环境下施工，可用以装载饮用水，食品或其他敏感性物质。 Not containing volatile organic solvent, the volume solids up to 100%, curing at room temperature 5-45The film possesses excellent high adhesion, excellent mechanical properties and easy application. The paint possesses ?excellent resistance to water, Because of using special curing agent, the dry film is not toxic, and dose not pollute potable water or food. Suited for application under badly ventilated condition, The tank painted with this product, can load potable water, food and other sensitive materials. Product Description 产品简介 双组份，施工前混合均匀，甲组份为漆料，乙组分为特种固化剂 Two components, component A is basic agent, and B is special curing agent, Stir till to even before application. Product Information 产品数据 Volume Solids 体积固体份 ≥50%ccording ??100% Dry Film Thickness? 干膜厚度 Recommended:200um 推荐为200微米 Theoretical Coverage 理论涂布率 3.33-3.57 m2/Kg 以200微米干膜剂 Practical? Coverage ?实际涂布率 Allow appropriate loss 允许适量损耗 Application Details 施工详述 ? Mix Radio 混合比 16 parts to 4 part by weight 重量比 16：4 Method of Application 施工方法 Airless Spray 无空气喷涂 Suitable for coating or repairing small area 适用于小面积涂装或修补 Brush or Roller 涂刷或辊涂 Suitable for coating or repairing small area 适用于小面积涂装或修补 Total output pressure depends on application Temperature and viscosity of paint 总输出流体压力视施工温度和漆液粘度而调节 Conventional Spray 传统喷涂 Not recommend 不适用 Thinner 稀释剂 Not necessary ， If no effect to application ,may Use C003 不需要，在不影响施工的情况下也可采用C003 Cleaner 油漆设备清洗剂 C003 Pot Life 使用期 20℃-60min分钟 35-40min分钟 Induction period 熟化时间 After mixing component A and B, can be Used immediately without ripening. 本产品甲、乙组份混合后不需熟化，可以马上使用 Storage 贮存期 One year 一年 Drying time 干燥时间 ? Substrate Temperature 底材温度， Touch Dry 表干 （h） Hard dry 硬干 h） Complete cure ? 完全固化 （d） Over coating Interval 覆涂间隔 Mix最短 Max最长 23 35 7 3 48 24 7 d 7 d 7 h 7 h 7 d 7 d ? Storage and Handling 贮存与管理 Storage 贮存 S