石材干挂工程施工方案.docxVIP

商丘建业十八城三期石材干挂工程施工方案编制：审核：审批；河南永畅建工集团有限公司二O一六年五月九日目录一、工程概况···································································21.l工程概况·······························································21.2．编制依据·····························································2二、施工总体安排·······························································22.l计划投入本工程嚣主要施工机械、设备······························22.2计划投入本工程的人员···············································2 2.3计划投入本工程的材料················································3 2.4施工前期准备工作·····················································4三、施工进度计划·······························································4四、主要施工方法·······························································4 4.1脚手架的搭救设、使用及拆除施工工艺······························4 4．2石材干挂安装上艺流程················································6 4.3施工要求·······························································6质量保证措施······························································8应注意的质量问题························································10成品保护··································································11清理方案··································································11安全保证措施·····························································12工程概况 1.1工程概况 河南省商市建业十八城三期项目，本工程为新建工程，外墙为干挂石材墙两，外挂石材面积约4000 m2左右。1.2编制依据 《建筑施工扣份斌钢管脚手架安全技术规范》（JGJ130-2002） 《金属与石材工程技术规范》(JGJ133-2001) 《硅酮建筑密封胶》 (GB/T14683-93)二、施工总体安排 2.1计划投入本工程的主要施工机械、设备序号 机械或设备名称数量 国别产地1台钻 3国产2切割机 3国产3 冲击钻6国产4胶枪3把5315电焊机3台6拖线电闸箱2台7手推车4台8水准仪1国产9大切1台2.2计划投入本工程的人员 1)人力资源使用计划根据该工程的工期要求和工作量，提前落实人力资源的来源，做好人力资源的统筹安排，成立强有力的架子队伍，担负施工任务，做到既保证人力资源充足又不窝工。(1)、人力资源专业工种配备：工程施工高峰期计划投入总人力资源：33人，平均入力资源：5人。人力资源专业工种配备表序号 劳动力资源、工种配置人数备注1架子工32石材安装工及打胶工203龙骨安装工84测量员15杂工1合计33 2.3计划投入本工程的材料 1)钢管：普通钢管，外径尺寸48 mm，壁厚3.5mm，钢管外表面锈蚀深度0.5mm，钢管弯曲符合规范要求．2)骨架：钢材选用要符合现行国家标准的规定。所有龙骨的钢材应其有质量证明书或检测报告，并应符合设计要求。若钢材表露有锈蚀、马甸或划痕等缺陷，其深度不得大于该钢材厚度负偏差值的l／2。主龙骨采用6#槽钢，横龙骨采用5#角钢，主龙骨与横龙骨主要受力构件截面主要受力部分厚度不小于3.3mm。 3)膨胀螺丝：应根据荷载大小确定，一般为M1O，