ppt课件-non-impulseyieldsensors.pptVIP

Combine Yield Monitors Current Yield Monitors Mass-flow sensor Volumetric-flow sensor Conveyor belt load sensor Trailer load sensor Torque transducer Basics of Yield Monitoring Possible Crops to Monitor Wheat and other grains Cotton Potato and Sugar Beets Beans Rice Specialty Crops Grapes, Tomatoes, Carrots, etc. Impulse Yield Sensors Impulse Flow Meter Force Vectors Dynamincs of an Impulse Flow Meter Non-Impulse Yield Sensors Capacitance Moisture Sensors Yield Mapping Trailer(Sugar Beet Harvest) Yield Mapping Trailer Measures change in weight in the trailer while allowing for comparison at different times. Can be used for any crop that is loaded into a trailer continuously while harvested. Conveyor Yield Monitor Corn Silage The drive shaft of the base unit powering the cutterhead, feedrolls, and front attachment, are instrumented with strain gauge torque transducers. Cutting power is linearly related to material feedrate. Material flow can be expressed as: Fr(t)=Yi(t)Sp(t)W Capacitance Moisture Sensors Sources of Yield Map Error Unknown swath width Time lag of grain through combine GPS error Multiple paths through combine Surging of grain through combine Grain losses Sensor Calibration Sources of Impulse Yield Sensor Error Grain Moisture Grain Test Weight Grain Temperature Grain Cultivar Grain Species Contamination Dirt Plant oils, sap, etc. Effect of Lag Time on Combine Yield Measurements Grain Flow Rate Comparison on Raw and Filtered Combine Flowrate Data Smoothing Effect of the Straw Walkers Correlation of Hand Harvested and Combine Yield Monitor Data – Colvin et al. Combine Yield Monitor and Satellite Estimated Wheat Yield Maps GPS Error in Corn – Loss of Differential Correction Signal Two Combines in the Field with only One Equipped with GPS Corn Yield Surface with Krieging Corn Yield Surface with Krieging Wheat Yield Under a Center Pivot Irrigation System Wheat Yield Under a Center Pivot Irrigation System Wheat Yield Under a Center Pivot Irrigatio