风冷冷风型空调机安装使用说明书剖析.docVIP

目　　录 CATALOGUE 机组外观和机组结构…………………………………….………………….………….....1 Unit outlook and structure 系统流程图…………………………………………………………………………….………...3 system flow chart 机组安装…………………………………………………………………………………………...4 Installation 调试……………………………………………………………………………………………...…..18 Test 五、使用…………….…………………………………………………………………………….…….....20 Operation 维护和保养…………………………………………………………………………….……….25 Maintenance 运行范围………………………………………………………………………….……………...26 Run scope 简易故障处理………………………………………………………………………………...27 Trouble disposal 一、机组外观和机组结构　Unit outlook and structure 机组外观 2、机组结构　　Unit structure 二、系统流程图 　system flow chart 风冷冷风型/电加热型空调机工作原理　 Working principle of the air-cooled cooling or electric heating air conditioner 热泵型空调机工作原理 Working principle of the heat-pump air conditioner 三、机组安装 1. 安装空间：　Installation space 确保机组安装位置周围有足够的空间以备操作、维修之用，同时也要保证气流循环畅通，不受阻碍并且没有短路。安装空间尺寸参见下图。 In order to ensure operation and maintenance convenient， enough space around the units must be ensured while installing．Air must flow freely without resistance and short circuit．Installation space size can be consulted as follows． 2. 安装定位 Installing location 应考虑电气接线、室内外机连接、排水管布置以及风管连接的方便。确保地面平整、水平，机组安装后倾斜度不应超过下图要求。 Must count for the convenience of electric wiring, connection of indoor and outdoor unit, arrangement of drain pipe and air duct connection while installation. Ensure ground to be flat and level, after installing, unit gradient can not exceed the limit showed in following chart. 地基应有足够的强度。机组重量和地脚螺钉固定位置参见以下各图。 Foundation should be intended enough. Unit weight and the foot screw fixed position is showed as following charts． 其它注意事项： Other attentions (1) 室内外机组安装位置要选择适当，必须安装在无日光照射、远离热源的地方。 Indoor and outdoor unit must be installed in the place which has no sunlight illuminated and far from heat resource. (2) 室外机组安装应考虑对建筑物外观的影响。 The influence on the building appearance must be considered when install the outdoor unit. (3) 安装安置应尽量选在管路短、弯曲少、高差小的地方。 　　　Installation should be situated in places where the pip