内置加热管的振动流化床中污泥干燥传热特性.pdfVIP

学兔兔 化 工 进 展 ·1438· CHEMICAL INDUSTRY AND ENGINEERING PROGRESS 2010年第29卷第8期 内置加热管的振动流化床中污泥干燥传热特性 范辞冬，王锐思，叶世超，齐亚兵，叶丹阳，潘霄恒，吴明钟 (四川大学化工学院，四川 成都 610065) 摘 要：采用内置加热管的振动流化床对污泥进行了干燥实验，考察了流化气速、进气温度、振动频率和内加 热功率对污泥干燥传热特性的影响，分析了体积传热系数的变化规律。结果表明，适度提高流化气速、进气温 度、振动频率和内加热功率，有利于提高体积传热系数，降低污泥湿含量 根据实验数据拟合出了体积传热系 数的经验公式，可将误差控制在30％以内。结论为污泥干燥的设计和操作提供实验依据。 关键词：污泥；内置加热管；振动流化床；湿含量；体积传热系数 中图分类号：TQ 028 文献标识码：A 文章编号：1000—6613(2010)08—1438—05 Heat transfer characteristic of sludge drying in vibration fluidized bed with inner-heating tubes FANCidong，WAN GRuisi，YEShichao，0IYabing，YEDanyang，PANXiaoheng，WUMingzhong (College ofChemical Engineering，Sichuan University，Chengdu 610065，Sichuan，China) Abstract：The drying of alcohol sludge was studied in a vibration fluidized bed with inner-heating tubes．Effects of gas velocity，gas temperature，vibration frequency and heating power on the drying characteristic of heat transfer were investigated．The variation of volumetric heat transfer coefficient was analyzed and the optimum operational conditions were obtmned．Results showed that a reasonable increase in gas velocity，gas temperature，vibration~equency and heating power could result in the decrease of sludge moisture by increasing the volumetric heat transfer coefficient．A correlation to calculate the volumetric heat transfer coefficient was established based on the experimental data with errors within 30％，which can serve as an important guidance for sludge drying design and operation． Key words：sludge；inner-hearting tubes；vibration fluidized bed；moisture；volumetric heat transfer