微孔膜气体分布器气液传质比表面积的研究.pdfVIP

学兔兔 化 工 进 展 ·1536· CHEMICAL INDUSTRY AND ENGINEERING PROGRESS 2009年第28卷第9期 微孔膜气体分布器气液传质比表面积的研究 刘有智，罗文浩，尚海茹，王其仓 (中北大学化学工程技术研究中心，山西 太原 030051) 摘 要：研究了以微孔膜作为气体分布器的反应器的气液传质比表面积，主要考察了气体流量、液面高度、表面 张力等操作因素对气液传质比表面积的影响。结果表明，气液传质比表面积随着气体流量的增大先呈增大的趋势， 到一定值时，开始呈减小趋势；随着表面张力的增大而减小；随着液面高度的增大缓慢减小。与传统塔设备比较， 微孔膜气体分布器的气液传质比表面积要高，分布器强化了气液传质过程。最后，运用量纲分析方法对试验数据 进行非线性回归得到关于气液传质比表面积的关联式，此式较好地吻合了试验数据。 关键词：微孔膜；无机陶瓷膜；气体分布器；气液传质比表面积 中图分类号：TQ 021．4 文献标识码：A 文章编号：1000—6613(2009)09—1536—04 Gas liquid mass transfer specific area in microporous membrane gas distributor LIU Youzhi，LUO Wenhao，SHANG Hairu，WANG Qicang (Rese~ch Center of Chemical Engineering and Technology，Noah University of China，Taiyuan 030051，Shanxi，China) Abstract：The mass transfer specific area of gas liquid of microporous membrane gas distributor Was investigated．While the different effect factors of specific surface area were reviewed，mainly including gas flux，liquid height，surface tension，etc．Experimental results represent mass transfer specific area of gas liquid Was increased with increased gas flux while gently decreasing at the high point，decreased with increased surface tension and decreased by inches with rised hquid height．TIley indicated mass transfer specific area of gas liquid was higher than that in conventional tower and microporous gas distributor extremely strengthened thegasliquidmasstransfer．Acorrelationwasnonlinearly regressed with experimentaldatabythewayofthe dimensionalanalysis．Th eexpression correlateswellthe experimenta