布尔台煤燃烧特性试验研究.pdfVIP

学兔兔 第 1期 锅 炉 制 造 No．1 2016年1月 BOILER MANUFACTURING Jan．2016 布 厶 、口 煤燃烧特性试验研究 朱安钰，曹 维，李洪涛 (华能巢湖发电有限责任公司，安徽巢湖238000) 摘 要：采用西安热工研究院的1 MW半工业性试验炉，对布尔台煤进行燃烧试验研究，分析其燃烧特性。试 验结果表明：由于布尔台煤的挥发份较高，着火稳定性较好。运行氧量在2．5％时，布尔台煤燃尽率相对较 低；随着氧量的增加，炉膛出口温度增加，对屏区结渣不利，运行氧量控制在3．5％左右合适。煤粉细度R 在 9—36％范围内对布尔台煤燃尽率影响较小，煤粉细度R 增加时，NOx排放增大，炉膛出口温度较高，对机组 燃烧不利，建议煤粉细度R 控制在18％。 关键词：半工业性试验炉；布尔台煤；运行氧量；燃尽率；煤粉细度 中图分类号：TK16 文献标识码：A 文章编号：CN23—1249(2016)Ol一0029—05 The Experimental Research on Combustion Characteristics 0f Buertai Coal Zhu Anyu，Cao Wei，Li Hongtao (Huaneng Chaohu Power Co．，Ltd．，Chaohu 238000．China) Abstract：Using the 1 MW serei industrial test boiler of TPRI，the combustion characteristics of bue~ai coal were analyzed．The results of the test show that：the ignition stability is better due to the high volatile of the coa1．When Operation oxygen is at 2．5％ ．the Buertai coal burn—out rate is rela- tively low；With the increase of oxygen consumption，the boiler outlet temperature increases，which is unfavorable for the slag of the screen．Then the oxygen content is controlled at about 3．5％ ．which is favourable．When the fineness of pulverized coal R9o is in the range of 9—36％ ，Buertai coal burn — out rate is less affected．When the fineness of pulverized coal R9o increases，the emission of NOx increases and the bioler outlet temperature is higher，which is unfavorable for the unit burning．It is suggested tha