搅拌机使用安全技术措施.docVIP

搅拌机使用安全技术措施 搅拌机使用安全技术措施作者：佚名 时间：2017-10-5 浏览量： 、搅拌机应设置在平坦坚实位置,用方木垫起前后轮轴,使轮胎搁高架空,以免在开动时发生走动。搅拌机架高使用时必须设操作平台,讲设防护拦杆。 2、电源接通后,必须仔细检查,经空车试转认为合格。方可使用。试运转时应校验拌筒转速是否合适,一般情况下,空车速度比重车稍快2~3转,如相差较多,应调整动轮与传动轮的比例。 3、拌筒的旋转方向符合箭头指示方向,如不符时,应更正电机接线。 4、检查传动离合器和制动器是否灵活可靠,钢丝绳有无损坏,轨道渡轮是否良好,周围有无障碍及各部件的润滑情况等。 5、对设有上料斗地坑的搅拌机坑口周围应垫高夯实,以防地面水流入坑内,上料轨道架的底端支承面应夯实或铺砖,轨道架的后面用方木支牢,防止工作时轨道变形。 6、开机后,经常注意搅拌机各部件的运转是否正常,停机时,经常检查搅拌机叶片是否打弯、螺丝有否打落或松动。 7、搅拌机料斗提升后,斗下不能有人过往,以免因制动器失灵发生意外。如确须在斗下检修或清理,须停机并将料斗用保险链条挂牢。 8、作业中,如果机械发生故障不能再运转时,应立即切断电源,将搅拌筒内混凝土清除干净,然后进行维修,如需要操作人员进入筒内清理时,除切断电源外,还应设专人在外监护或卸去熔断器并锁好电闸箱后,方可进人工作。 9、当混凝上搅拌完毕或预计停歇1小时以上,除将余料出净外,应用石子和清水倒入拌筒内,开机转动,把粘在料筒上的砂浆冲洗干净后全部卸出。料筒内不得有积水,以免料筒和叶片生锈。同时还应清理搅拌筒外积灰,使机械保持清洁完好。 0、下班后及停机不用时,将保险丝取下,以策安全,料斗应落至坑内,必须升起则应用链条扣牢。 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work, set a good XX students ideologic