搅拌站废水作为混凝土拌和用水的试验研究.pdfVIP

学兔兔 2015年 第 2期 (总 第 304期 ) 混 凝 土 预 拌 混 凝 土 Number 2 in 2015(Total No．304) Concrete READY MIXED CONCRETE doi：10．3969／j．issn．1002—3550．2015．02．028 搅拌站废水作为混凝土拌和用水的试验研究 张凯峰，姚 源，赵世冉。刘 康，王信鸽，刘行宇 (中建商品混凝土西安有限公司，陕西西安7101 16) 摘 要：通过水泥净浆试验和胶砂试验，研究了不同浓度废水在不同掺量下对水泥标准稠度需水量、凝结时间及水泥砂浆流动 度、强度影响规律。在此基础上研究了1％浓度下，不同掺量废水对C60混凝土强度的影响规律。结果表明：随着废水掺量增加， 水泥胶砂的流动度降低，但降低幅度不大，凝结时间延长；不同浓度废水对胶砂试块强度影响规律不同，且存在最佳掺量。l％浓 度下，废水掺量为80％时，C60混凝土抗压强度达到最高。 关键词：搅拌站废水；浓度；水泥；混凝土；性能 中图分类号：TU528．01 文献标志码：A 文章编号：1002—3550(2015)02—0101—03 Experimental study on wastewater from concrete hatching plant as mixing concrete water ZHANG Kaifeng，YAO Yuan，ZHA0 Shiran，Lily Kang，WANG Xinge，U UXingyu (China Construction Ready—mixed Concrete Co．，Ltd of Xian，Xihn 710116，China) Abstract：According to cement paste test and mortar test，the effects of water consumption of standard consistence，setting time and mortar flowability．strength was studied under different concentration and dosage of wastewater．On this basis．under l％ concentration of wastewater，the influence on the strength of C60 concrete under different dosage of wastewater was also analyzed．The results showed that with the increase dosage of wastewater，the flowability of cement mortar is reduced，but the reduction is not big，and setting time prolonged；With different concentration wastewater was added into mortal block，the regularity on its strength is diffrengt，and each had its best dosage．Under concentration of l％．waste water content add to 80％．C60 concrete had the highest compressive strength． Key words：mixing plant waste water；concentration；cement；concrete；performance 表1 水泥的基本性能 0 引言