铁尾矿制备加气混凝土试验研究.pdfVIP

学兔兔 斩 建 中国科技核心期刊 铁尾矿素Ij备加气混凝土试验研究 韩晨，吴焦，刘桃红 (武汉科技大学 资源与环境工程学院，湖北 武汉 430081) 摘要：以湖北黄石金山店铁尾矿为主要原料制各加气混凝土，研究了铝粉和碱用量对加气混凝土密度的影响，考察了尾矿细 度及石英粉用量对加气混凝土密度及抗压强度的影响，并对样品进行了XRD和SEM微观分析。结果表明：当铝粉用量为0．1％，碱用量 为0．4％，石英粉用量为20％，并对尾矿磨细处理制备的样品达到GB 11968--2006《蒸压加气混凝土砌块》A3．5、B07级加气混凝土合 格品要求，制品中水化产物主要为托贝莫来石和CSH凝胶，形成致密的网状结构，对强度的提高起到积极作用。 关键词：低硅铁尾矿；加气混凝土；性能；微观结构 中图分类号：TU528．2 文献标识码：A 文章编号：1001—702X(2013)11-0049—04 Experimental study on aerated concrete with iron ore railings HAN Chen，WU ∞，L1U Taohong (College of Resource and Environmental Engineering，Wuhan University of Science and Technology，Wuhan 430081，Hubei，China) Abstract：Aerated concrete is prepared by taking the iron ore railings in Hubei Huangshi Jinshandian as the main raw materia1．The effect of aluminum powder and alkali dosage on density of the aerated concrete was studied，the effect of railings fineness and quartz powder dosage on density and compressive strength of the aerated concrete was investigated，and the samples were characterized by XRD and SEM microscopic analysis．The results show that：when the amount of aluminum powder was 0．1％， alkali amount was 0．4％ ，quartz powder amount was 20％ ，the railings were ground fine，the prepared sample can meet the qualification requirement of A3．5，B07 level aerated concrete as defined in national standard GB 1 1968--2006”Autoclaved aerated concrete block”．The hydration products are mainly tobermorite and CSH gel，forming a dense network structure，and playing an active role in strength improvement． Key words：low si