活性炭孔结构对煤层甲烷选择吸附行为的影响-学兔兔 www.xuetutu.com.pdfVIP

学兔兔 石 油 化 工 2013年第42卷第7期 PETROCHEMICAL TECHN0L0GY ·749· 活性炭孔结构对煤层甲烷选择吸附行为的影响 周 静，柏任流，郑开波 (黔南民族师范学院 化学与化工系，贵州 都匀 558000) [摘要]采用不同含量的过氧化氢溶液和硝酸溶液对商用活性炭AC一1进行改性并经He—H：高温热处理，同时对石油焦活性炭 进行THe—H 高温热处理以作为对比。采用低温N：物理吸附、TPD和Boehm酸碱滴定等手段对活性炭进行了表征。以甲烷和N： 混合气为煤层甲烷模型气，考察了活性炭孔道结构对甲烷选择吸附行为的影响。实验结果表明，不同改性方法对活性炭孔道 结构的改变有明显的影响，经He—H，高温热处理后不同的活性炭具有相似的表面化学性质；活性炭的孔径是选择吸附甲烷的首 要因素，最佳孔径范围为0．71～0．74 nm；微孔比表面积决定了甲烷的吸附容量，微~Ll：t表面积越大，甲烷富集容量越大。 [关键词]煤层甲烷；选择吸附；活性炭；孔结构 [文章编号]1000～8144(2013)07—0749—06 [中图分类号]TQ 424．1 [文献标志码]A Eflfect Of Pore Structure of Activated Carbon on Selective Adsorption of Coal-Bed Methane ZhouJing，BaiRenliu，ZhengKaibo (Department ofChemistry andChemicalEngineering，QiannanNormalCollegeforNationalities，DuyunGuizhou 558000，China) I Abstract}Activated carbon was modified with HNO3 and H2O2，and by thermal treatment in He- H2 to improve its pore structure．which was beneficial to the adsorption of coa1．bed methane on it．The modified activated carbons were characterized by means of the physical adsorption of N，at 77 K， TPD and Boehm titration．It was shown that the modifications affected the pore structure of the samples significantly，while the superficial chemical properties were similar after the thermal treatment in He— H，．Pore diameter iS the major factor affecting the selective adsorption of methane on the activated carbons．and the optimum pore diameter is in the range of 0．7 1—0．74 nm．The specific surface area of the micropores affects the adsorption capacity ofthe activated carbons，and the amount ofthe enriched methane increases with the increa