范长信--P91、P92研究进展.pdf

TPRI TPRI TPRI P91/P92钢研究进展 范长信 2010.11 温州 Thermal Power Research Institute 目录 Contents TPRI 一、 P92钢的蠕变特性研究 Study on creep behavior of P92 二、P92钢热时效特性研究 Study on thermal aging characteristics of P92 三、 P92钢焊接接头的性能研究 Study on P92 weld joint 四、 P91/P92钢的硬度指标控制 Hardness control of P91/P92 五、 P91钢蠕变-疲劳损伤试验研究 Study on creep-fatigue behavior of P91 steel TPRI 一、 P92钢的蠕变特性研究 Study on creep behavior of P92 Partly cooperated with John Hald at Technical University of Denmark (DTU) 1.显微组织研究 Microstructures TPRI as received 600ºC/110MPa/60628h o 600 C / 120MPa / 34660h P92钢原始组织和蠕变断裂试样的组织 Microstructures of as-received and crept specimens of P92 TPRI u P91/P92钢经长时间运行或蠕变,在光学显微镜下其金相组织变化难以辨别 It is difficult to observe the changes of microstructures of P91/P92 by OM after long-term exposure or creep. u 蠕变后，亚晶尺寸增大 The sub-grain sizes in crept samples are wider than that in as- received state. u 蠕变后，位错密度下降 The dislocation density decreases in crept samples. u 蠕变后，第二相长大粗化和新相析出长大 Secondary phases coarsen and some new type of phases precipitate and coarsen. 2.Laves相研究 Study on Laves phase TPRI SEI 5500 × BEI 5500 × SEI 20000 × BEI 20000 × 扫描电镜下运行5万小时的P92钢主蒸汽管道组织