环境工程卧螺离心机文章.pdfVIP

两级串联卧螺离心机用于飞灰水洗料浆固 ∗ 液分离试验研究   1,3 1,3 2 1,3 2 朱延臣 ，顾军 ，张国亮 ，蔡文涛 ，练礼财 （1.北京建筑材料科学研究总院，北京100041；2.北京市琉璃河水泥有限公司，北京 102403；3.固废资 源化利用与节能建材国家重点实验室，北京 100041）   摘要：采用两级串联卧螺离心机对飞灰水洗料浆进行了现场固液分离试验，首先研究了转鼓转速、差转速和溢流半径等对分离 效果的影响，选择并确定了合适的操作参数，然后进行了长时间连续运行试验，结果分离后平均泥饼含水率在39.8%，平均滤液 含渣率在0.6%，平均固相回收率达98.1%，分离效果明显优于真空过滤机，另外卧螺离心机一直运行平稳，未出现影响正常运 行问题，说明两级串联卧螺离心机可完全代替真空过滤机。 关键词：两级；卧螺离心机；飞灰；固液分离    STUDY OF SOLID-LIQUID SEPARATION TEST ON FLY ASH WATER SLURRY BY USING TWO-STAGE SERIES DECANTER CENTRIFUGE ZHU Yanchen1,3 GU Jun1,3 ZHANG Guoliang2 CAI Wentao1,3 LIAN Licai2 （1.Beijing Building Materials Academy of Science Research,Beijing100041,China;2.Beijing Liulihe Cement Co.,Ltd.,Beijing102403,China;3.State Key laboratory of Solid Waste Reuse for Building Materials,Beijing100041,China ） Abstract: A field solid-liquid separation test on fly ash water slurry was studied by using two-stage series decanter centrifuge.Firstly the drum rotating speed,differential rotating speed and radius of the overflow effect on the separation were studied and the appropriate operating parameters were determined. Then continuous operation test had been doing for a long time, and the results shows that the average mud cake moisture content is 39.8%, the average filtrate cinder rate is 0.6%, and the average solid phase recovery rate is 98.1%. The separation effect is superior to that of the vacuum filter.In adition the decanter centrifuges had been running smoothly, and the problems affecting normal operation didn’t exist.The test shows that two-stage series decanter centrifuge can comple