生物膜填料塔处理高流量负荷下低浓度甲苯废气的初探.pdfVIP

第 5 卷第 5 期 环境污染治理技术与设备 Vol . 5 , No . 5 2 0 0 4 年 5 月 Techniques and Equipment for Environmental Pollution Control May 2 0 0 4 生物膜填料塔处理高流量负荷下 低浓度甲苯废气的初探 李章良　孙　石 ( 昆明理工大学环境科学与工程学院 , 昆明 650093) 摘 　要 　采用净化甲苯专用菌种对生物膜填料塔净化处理高流量负荷下低浓度 甲苯废气的技术进行了初步实验研 3 3 究 。实验结果表明 ,当气体流量在 08 m / h 、进口浓度为 105 mg/ m 、停留时间 183 s 时 , 甲苯的去除率可达到 6190 % ,出口 ( 3) 甲苯浓度低于国家对现有企业的排放标准 ≤60 mg/ m 。适宜的操作温度应控制在 19～25 ℃之间 ,氮磷营养添加量的配比 应控制为 CN∶P∶= 2005∶1∶,操作压降与气体流量呈线性关系 。结合实验数据 ,对相关的基础理论进行了初步探讨 。 关键词 　生物膜填料塔 　高流量负荷 　低浓度甲苯废气 　废气净化 An approach to purif ication of waste gases containing toluene in low concentrations with high airflow load by using a biotrickling f ilter Li Zhangliang 　Sun Peishi ( Institute of Environmental Science and Engineering ,Kunming University of Science and Technology , Kunming 650093) Abstract 　Purification of waste gases containing toluene in low concentrations with high airflow load was prelimi 3 narily investigated by using a biotrickling filter . The experimental results indicated , under the conditions of 08 m / h 3 of inlet airflow , 105 mg/ m of inlet concentration and residence time for 183 s , the maximum removal efficiency of toluene in waste gases reached at 61. 90 %. The treated waste gases can be discharged in the situation of satisfying the national emission standard . In the operation , the optimum gas temperature was in the ran