室内风机关机后不停及未开机风机就运行（The indoor fan is shut off and the fan is running）.docVIP

下载本文档

24
0
约3.82万字
约 13页
2017-07-15 发布于河南
举报
版权申诉

室内风机关机后不停及未开机风机就运行（The indoor fan is shut off and the fan is running）.doc

1、原创力文档（book118）网站文档一经付费（服务费），不意味着购买了该文档的版权，仅供个人/单位学习、研究之用，不得用于商业用途，未经授权，严禁复制、发行、汇编、翻译或者网络传播等，侵权必究。。
2、本站所有内容均由合作方或网友上传，本站不对文档的完整性、权威性及其观点立场正确性做任何保证或承诺！文档内容仅供研究参考，付费前请自行鉴别。如您付费，意味着您自己接受本站规则且自行承担风险，本站不退款、不进行额外附加服务；查看《如何避免下载的几个坑》。如果您已付费下载过本站文档，您可以点击这里二次下载。
3、如文档侵犯商业秘密、侵犯著作权、侵犯人身权等，请点击“版权申诉”（推荐），也可以打举报电话：400-050-0827(电话支持时间：9:00-18:30)。
4、该文档为VIP文档，如果想要下载，成为VIP会员后，下载免费。
5、成为VIP后，下载本文档将扣除1次下载权益。下载后，不支持退款、换文档。如有疑问请联系我们。
6、成为VIP后，您将拥有八大权益，权益包括：VIP文档下载权益、阅读免打扰、文档格式转换、高级专利检索、专属身份标志、高级客服、多端互通、版权登记。
7、VIP文档为合作方或网友上传，每下载1次，网站将根据用户上传文档的质量评分、类型等，对文档贡献者给予高额补贴、流量扶持。如果你也想贡献VIP文档。上传文档

室内风机关机后不停及未开机风机就运行（The indoor fan is shut off and the fan is running）

室内风机关机后不停及未开机风机就运行（The indoor fan is shut off and the fan is running） Section 2 maintenance cases of electrical control system Case 1, controllable silicon, indoor noise Fault phenomenon: after shutdown, the indoor fan slowly turns, and the noise of the ear is emitted after it is turned on. Reason analysis: according to customers reflect and phenomenon analysis, a preliminary judge for indoor electrical power supply failure, check the indoor fan power supply voltage and 100 v voltage motor shutdown condition, indoor motor is still slow continuous running after shutdown, indoor electrical heating make plastic electric frame meet the thermal deformation, plastic sealed motor position deviation, this would have resulted in a consistent wind flow leaves into the chassis, harsh noise, and there is a burning. The result is that the fan controls the damage of silicon controlled silicon. Solution: change master control board. Experience: fission hang fan speed is controlled by thyristor, indoor machine when the power supply voltage is low or volatile, will cause the silicon controlled single-phase breakdown, when stop the indoor fan will still be voltage, the motor will still slow turning, because the SCR for single-phase breakdown, motor power supply non-sinusoidal waveform, motor running is not smooth, the noise is bigger. Case two, the indoor fan shutdown and the unturned fan will run Malfunction: after shutdown, the indoor fan will not stop and the fan will run. Cause analysis: according to the user reflect the fault phenomena, electricity of indoor fan operation, with remote boot after shutdown, indoor fan is still running, the preliminary judgment for indoor electrical power supply failure, check the indoor fan power supply voltage, current status, or shutdown under loading condition on the motor output voltage 158 v, so after electrify indoor motor running, thus judged the fan control thyristor damage. Solution: replace the same model controller and the test machine