嵌入式电袋复合除尘器在燃煤电厂的细颗粒物排放研究李枭鸣.docVIP

嵌入式电袋复合除尘器在燃煤电厂的细颗粒物排放研究 摘要：福建龙净环保股份有限公司引进国外先进技术并开发出FEH嵌入式电袋复合除尘器。FEH嵌入式除尘器在燕钢电厂6#成功投运，为了研究该电袋复合除尘器电区及混合区的投运模式对PM1、PM2.5、PM10三级细微颗粒浓度的影响，利用DPI采样仪、TH880-FⅣ型微电脑烟尘平行采样仪、Testo 350-XL烟气分析仪等对6#在5种不同工况下对其进行了性能测试的试验，同时选取了2种相同工况对5#机组的前电后袋电袋复合除尘器进行对比研究。嵌入式电袋复合除尘器在5种工况条件下对于粒径≦PM1的粒子除尘效率最低，整体上对PM2.5~PM10的粒子除尘效果最佳。PM1~PM2.5、PM2.5~PM10、≦PM10的粒子在不同工况条件下的除尘效率效果不一。 关键词：嵌入式电袋复合除尘器；前电后袋电袋复合除尘器；PM1；PM2.5；PM10 Abstract：Fujian Longking Co., Ltd introducted of foreign advanced technology and the development of FEH embedded electric bag composite dust collector. FEH embedded dust collector have operated successfully in 6# furnace of Yan steel power plant.In order to study the influence of the electric efip area and mixed area operation mode of PM1, PM2.5, PM10 three grade fine particle concentration, The performance test of the 6# furnace was carried out under 5 different conditions by using the DPI sampling instrument, the TH880-F type microcomputer dust parallel sampling instrument, the 350-XL Testo flue gas analyzer and so on, At the same time, the 2 kinds of the same conditions on the 5# unit of the former electric bag bag electric bag composite dust collector were compared and studied. Embedded electric bag composite dust collector in 5 kinds of conditions for particle size less than PM1 particle removal efficiency lowest，On the whole, the effect of particle removal of PM2.5~PM10 is the best, PM1~PM2.5, PM2.5~PM10, PM10 particles in different conditions dust removal efficiency is not an effect. Key Words: Embedded electric bag composite dust collector, Electric bag composite dust collector, PM1, PM2.5, PM10 0 引言 我国是个燃煤大国，由燃煤排放出的细颗粒物的量是巨大的，而对于燃煤电厂烟气中PM10、PM2.5、PM1排放特性这方面研究较少。福建龙净环保股份有限公司从美国能源与环境研究中心（EERC）引进嵌入式电袋（AHPC)专利技术[1]。通过消化吸收并结合公司FE电袋技术开发了FEH嵌入式电袋复合除尘器。该除尘器已于去年9月在燕山钢铁6#机组220t/h循环流化床锅炉成功投运。为了解掌握嵌入式电袋复合除尘器电区及混合区的投运模式对PM1、PM2.5、PM10[2]三级细微颗粒浓度的影响，对其进行了性能测试的试验。同时与5#机组的前电后袋电袋复合除尘器进行了对比试验。 1 仪器与方法 1.1 试验仪器 （1）DPI细颗粒物（PM1、PM2.5、PM10）采样仪，1套。 （2）TH880-FⅣ型微电脑烟尘平行采样仪，1套。 （3）Tes