电视机中周调试（Middle cycle debugging of TV set）.docVIP

电视机中周调试（Middle cycle debugging of TV set） Step: 1. weeks in the week or replacement containing capacitance of the original, after the TV is inserted in the TV antenna, no signal state. 20 thousand meter DC voltage monitoring circuit blocking the output voltage of AFT, for the M11 movement, AFT voltage test points put optional integrated circuit AN5132 in 6 feet, TA two test points in the optional movement TA7680 13 feet, TDA microcontroller core can be tested in the TDA8362 44 feet. 3. with no sense of rotation in AFT weeks repeated screwdriver adjustment and image detection in several weeks, the AFT voltage reaches the maximum value. The adjustment to observe the maximum peak point in the curve should be adjusted, this point, AFT voltage will become small. After adjustment for M11, and TA two core AFT core voltage can reach 6 to 7 volts or more, AFT voltage standard value at about 6.5V. TDA microcontroller core TV only a week, it is located in the TDA8362 2`3 pin, AFT standard voltage value at about 4V, the adjusted voltage can reach 4 to 6 volts. Through the above method after adjustment for AFT weeks and weeks in image detection at the optimal adjustment point, as long as no other TV fault, automaticsearchstation operation can complete a one-time adjustment, a success rate of over 90%. Adjust skills and should pay attention to the problem 1. TV should be set up in an empty channel, so that more accurate adjustment. 2. new models in the week should be the same as the prototype, the best use of large manufacturers of the original brand in a week. If the 3. do not have the new week in week in the replacement of the original capacitor should be similar to the prototype in the week with capacity. Changes in 4. weeks by adjusting the AFT voltage monitoring, can judge the original machine in the week is degenerate, the new week is appropriate. Good quality in the week, in the two weeks in AFT, the voltage changes with the adjustment of core sensitive and AFT voltage val