转盘过滤器.docVIP

转 盘 式 过 滤 器 Rotary Filter (滤布滤池) (Cloth Media Filtration)  转盘过滤器(滤布滤池) Rotary Filter (Cloth Media Filtration) 工作原理 Operation Principle 转盘式过滤器由中心转鼓、转盘、反洗系统和配套控制电气系统等组成。转 盘固定在中心转鼓周围，并与中心转鼓具有连通孔。原水（污水）由中心转鼓的 一端开口流入转鼓内，并通过连通孔进入各转盘，转盘两侧装有过滤布，过滤布 为不锈钢丝或聚酯丝编织而成，过滤孔径最小可达 10μ m。原水通过过滤布过滤 后，清水流出过滤布，从过滤水出口排出系统外。 The rotary filter is composed with rotary drum, rotary discs, backwash system and configured electrical control system. The rotary discs are fixed around the rotary drum with interlocking holes. The raw water (sewage) flows from the open end of rotary drum into the rotary drum and comes into each rotary disc via interlocking holes. The rotary disc can be equipped with filtration cloth on both sides that is weaved by metal wire or other organic materials with the diameter of filtration hole less than 10μ m. After the filtration of raw water by filtration cloth, the clean water flows out from the filtration cloth and then drains off the system through the exit of filtered water. High efficiency fiber rotary disc Backwash water Inflow Exit of filtered water 随着过滤的进行，过滤布内侧的截留杂质不断增加，过滤压差随之增加，透 过滤布的水量减小。当杂质堆积到一定程度，中心转鼓液位达到设定值，需要进 行反洗，将过滤布内侧堆积的杂质反洗出。 With ongoing filtration, the residual impurities inside filtration cloth will increase continuously, and the same is true for differential pressure of filtration. Meantime, the water flow is reduced through the filtration cloth. When the impurities are accumulated to a certain extent and the level of rotary drum reaches the preset value, it is necessary to conduct the backwash and get rid of the accumulated impurities inside filtration cloth. 反洗水泵抽取透过过滤布的清水，喷洒到过滤布外侧，将过滤布内侧的截留 杂质冲洗下来，冲洗后污水掉落在接液盘内，然后排出装置外。 The backwash water pump draws out clean water through filtration cloth to sprinkle on the outside of filtration cloth until the residual impurities come off. After rinsing, the sewage drops into catchment tray and then drains off the device. 反洗时转盘旋转，反洗水喷洒不同角度的过滤布，直至转盘旋转一周，过滤 布全部经过清洗，反洗停止，重新进入静止过滤过程，直至再次进行反洗。 The rotary discs tak