on heating the cold does not lose gathering technology（加热冷不失收集技术）.docVIP

On heating the cold does not lose gathering technology [Paper Keywords] cold cold gathering input management [Abstract] analyzed the impact of cold input shaft of the main factors, namely, crude oil freezing point, crude oil impurities, pipeline roughness, length of the pipeline, and integrated water and other factors, according to the actual production of the key parameters for analysis. To carry out the cold output not heat set oil gathering and transportation technology, cold worked out for lost oil production crew set to lose condition, that the scientific methods of operation and problems, is conducive to production management. Input that is mixed with the so-called cold water does not heat set oil temperature, oil transfer station in the self-turn on the water temperature is about continuous stable at 350C, mixed with water pressure higher than the measurement between 1.4MPa, 0.6MPa single well back pressure is not higher than the case may be mixed with water at room temperature without the use of heating oil set way, all stations can be furnace outage. 1 there is a problem (1 back pressure from the normal production of 80 wells random comparison, based on lower production values ??and current changes (when the oil pressure to 0.8MPa amount of oil, oil pressure reached 0.60MPa when the washing lines. To facilitate the production management, we rinse cycle route set at more than 7 days, calculate the 41% of the wells (33 may continue to lose view of the cold check, 24% of the wells (19 production of cold transmission from the management to consider largely abandoned the cold output . (2) environmental factors produce cold lost in the process of cooling output for abnormal conditions (back pressure greater than 0.6MPa should resume immediately watered to avoid pipeline plugging due to 113-doped pump station pump efficiency is low, usually mixed with water pressure to run only can reach 1.2 MPa. must be watered in the minimum amount of