YA系列增安型三相异步电动机.pdf

YA系列增安型三相异步电动机 Series YA Increase-Safety Three-Phase Induction Motors 南阳防爆集团有限公司 1 1概述 YA系列增安型三相异步电动机（以下简称增安型电动机）是按 GB3836.1-2000《爆 炸性气体环境用电气设备 第 1部分：通用要求》和GB3836.3-2000《爆炸性气体环境用 电气设备 第 3部分：增安型“e”》的规定设计制造的，其防爆标志分为 ExeⅡT1、Exe ⅡT2、ExeⅡT3，分别适用于工厂中引燃温度为T1、T2、T3组的可燃性气体或蒸气与空气 形成的爆炸性温合物场所的设备上。 本系列电动机的功率等级与安装尺寸的对应关系对 ExeⅡT1、ExeⅡT2组的与 Y系列 相同，对ExeⅡT3组考虑到增安型电动机有降低温升及t时间不得小于5s的要求，2极电 E 动机从H160，4极从H180起，较Y系列电动机降低一功率等级，其余的功率等级与Y系 列保持一致。本系列电动机具有效率高、起动转矩大、噪声低、振动小、温升裕度大、性 能优良、使用安全可靠、寿命长等优点。 本系列电动机的功率范围为0.55～315Kw，机座中心高80～400mm。 YA系列增安型电动机主体外壳的防护等级不低于IP54，接线盒外壳防护等级不低于 IP55，电动机的冷却方法为IC411，并可按要求制成户外型（W）、户外防中等腐蚀型（WF1）。 1 General Description Series YA Increased Safety Three Phase Induction Motors (hereafter designated as increased safety motors) are designed and manufactured in accordance with China National Standards: GB 3836.1-2000 Electrical Apparatus for Explosive Gas Atmospheres Part 1: General Requirements GB 3836.3-2000 Electrical Apparatus for Explosive Gas Atmospheres Part 3: Increased Safety e The explosion protection marking manifests as Ex e ⅡT1, Ex e ⅡT2 and Ex e ⅡT3. This series motors are safely used separately on the equipment in the factories where are the locations present explosive mixtures formed by flammable gases or vapours of ignition temperature group T1, T2 or T3 and air. For Exe ⅡT1 and Exe ⅡT2 motors, the correlation of output ratings and mounting arrangements of this series motors are the same with those of series Y motors. But for Exe ⅡT3 motors, considering the specifications that the increased safety motors should reduce temperature rise and t time should not less than 5s, 2-pole motors H160 and above and 4-pole motors H180