浸没对置撞击流的液相混合行为研究-高校化学工程学报.pdfVIP

第 30 卷第 2 期 高 校 化 学 工 程 学 报 No.2 Vol.30 2016 年 4 月 Journal of Chemical Engineering of Chinese Universities Apr . 2016 文章编号：1003-9015(2016)02-0311-07 浸没对置撞击流的液相混合行为研究 张建伟, 张学良, 冯 颖, 王诺成 (沈阳化工大学 能源与动力工程学院, 辽宁 沈阳 110142) 摘 要：利用无干扰流场测试手段——平面激光诱导荧光技术(PLIF)，对浸没对置撞击流混合反应器在等动量撞击下 的浓度场进行分析，并分析比较对称撞击和不对称撞击下的液相混合行为。利用混合均匀度 U 和均匀混合时间 τ 定 95 量描述测量平面的示踪剂浓度分布，得出其在不同内径比、不同喷嘴间距下的变化规律，并进一步分析对称撞击时， 两喷嘴出口流体的不同动量比对混合的影响。研究发现：在小喷嘴间距 L 10D (L 为喷嘴间距；D 为两对置喷嘴内径 和的平均值)下，等动量撞击时，对称撞击的混合效果要优于不对称撞击；对称撞击和不对称撞击的最优混合间距均为 L = 3D 。对称撞击时，两喷嘴出口流体的动量比越接近于 1，越有利于液相混合。 关键词：撞击流；液相混合；平面激光诱导荧光技术；混合均匀度；混合时间 中图分类号：TQ021.1 文献标识码：A DOI ：10.3969/j.issn.1003-9015.2016.02.009 Study on Liquid Mixing Behavior within a Submerged Impinging Stream Mixer ZHANG Jian-wei, ZHANG Xue-liang, FENG Ying, WANG Nuo-cheng (School of Energy and Power Engineering, Shenyang University of Chemical Technology, Shenyang 110142, China) Abstract: Concentration fields of two streams with equal momentum in a submerged impinging stream mixer was studied by non-intrusive planar laser inducing fluorescence technique, and the liquid mixing behavior of symmetric and asymmetric impinging was analyzed. The concentration distribution of a tracer was evaluated quantitatively based on mixing uniformity and mixing time, and the effect of different internal diameter ratios and separation distances on tracer distribution was studied. The influence of momentum ratio of two streams on mixing was discussed under symmetric impinging. The results show that symmetric operation exhibits better