多尺度聚丙烯纤维混凝土抗裂性能的试验研究-IngentaConnect.PDFVIP

　 第37卷第8期 煤　 　 炭　 　 学　 　 报 Vol.37　 No.8　 　 2012年 8月 JOURNAL OF CHINA COAL SOCIETY Aug.　 2012　 - - - 　 　 文章编号:0253 9993(2012)08 1304 06 多尺度聚丙烯纤维混凝土抗裂性能的试验研究 梁宁慧,刘新荣,孙　 霁 (重庆大学 土木工程学院 山地城镇建设与新技术教育部重点实验室,重庆　 400045) 摘　 要:选用4种尺寸的聚丙烯细纤维与2种尺寸的聚丙烯粗纤维,在相同拌合工艺、相同配合比 条件下进行单掺及混掺混凝土的开裂性试验。 试验表明:对聚丙烯纤维,同掺量时,长径比较小者, 早期抗裂效果相对较优;细纤维在塑性态混凝土中的阻裂效应优于粗纤维;粗纤维在硬化阶段的抗 裂效果优于细纤维。 鉴于此结果,将聚丙烯粗细纤维进行混掺,使其在混凝土凝结硬化的不同时期 能协同作用,不仅能够阻止混凝土的塑性开裂,而且可推迟硬化阶段裂缝的形成,从而有效控制混 凝土裂缝,达到阶段抗裂、层次抗裂的目的。 关键词:多尺度;聚丙烯纤维;塑性态混凝土;阻裂效应 中图分类号:TU528．01　 　 　 文献标志码:A Experimental study of crack resistance for multi-scale polypropylene fiber reinforced concrete LIANG Ning-hui,LIU Xin-rong,SUNJi (College of Civil Engineering,Key Laboratory of New Technologyfor Construction of Cities in Mountain Area,Ministry of Education,Chongqing University, Chongqing　 400045,China) Abstract:Cracking tests of fine polypropylene fibers in four sizes and thick polypropylene fibers in two sizes,sing- doped and mix-doped with concrete by same mixing technique and in same dose ratio,were completed.The results show that,underthesamedosage,thesmallertheaspectratiois,thebettertheeffectonearlycrackingis;thecrack-re- sist effect of fine fibers in plastic phase of concrete is better than that of the thick ones;the crack-resistant effect of thickfibersduringhardeningphaseisbetterthanthat of thefineones.Accordingtotheabove,themixedblendoffine andthickpolypropylenefiberswilldisplay differentfunctionsduringdiversehardeningphases,anditwillnotonlypre- vent plastic cracking of the concrete,but also delay the cracksformation,so as to effectively reduce cracks and reach the crack-resist purposes in diffe