刻日轮胎橡胶粉对砂浆力学性能与导热系数影响.pdfVIP

学兔兔 2013年第 9期(总第 287期 ) 混 凝 土 预 拌 砂 浆 Number 9 in 2013(Toml No．287) Concrete READY MⅨED MORTAR doi：10．3969~．issn．1002-3550．2013．09．033 废旧轮胎橡胶粉对砂浆力学性能和导热系数的影响 陈建银1．2，张云莲z，孔德玉 (1．浙江工业大学 建工学院，浙江 杭州 310032；2．浙江科技学院 建工学院，浙江 杭州 310023) 摘 要：采用4种细度的废旧轮胎橡胶粉等体积代砂成型橡胶砂浆试件，测定其抗压抗折强度、导热系数。试验结果表明：较粗 橡胶粉制备的砂浆力学性能较好而保温性能稍差；橡胶砂浆的抗压抗折强度、导热系数均随橡胶粉掺量的增加而降低，压折比也 随之降低，橡胶粉掺量大于40％后，压折比下降加快，达到60％时，橡胶砂浆压折比均降至3．0以下；橡胶掺量为20％时，橡胶砂 浆导热系数降至空白砂浆试件的1／2；橡胶砂浆的导热系数与表观密度呈现二次曲线正相关。 关键词：橡胶粉；橡胶砂浆；压折比；导热系数掺合料；高强；超高强；高性能；混凝土；水化活性因子；减水剂；增量系数 中图分类号：TU528．041 文献标志码： A 文章编号： 1002—3550(2013)09—0l15一O3 Influence of the waste tire crumb rubber on mechanical properties and heat—conduct coefficient of cement mortar CHENJianyin1,2 ZHANG Yunlian2 KONGDeyu (1．ZhejiangUniversityofTechnology，School ofCivilEngineering andArchitecture，Hangzhou 310032，China； 2．ZhejiangUniversityofScienceandTechnology，School ofCivilEngineeringandArchitecture，Hangzhou 310023，China) Abstract： Four kinds of waste tire crumb rubber with different fineness were used to partially replace fine aggregate in mortar speci— mens．The mechanical properties and heat—conduct coefficient of rubberized mortar were tested．The results show that coarse crumb rubber leads to bigger compressive and flexural strength but worse thermal insulation performance．The compressive and flexural strength， heat-conduct coefficient as well as the ratio of compressive strength to flexural strength reduce with the increasing of dosage of crumb rub— ber．Th e ratio of compressive strength to flexural strength reduces much quickly when crumb rubber dosage surpasses 40