高强再生轻骨料和玻璃微珠配制轻质高强混凝土研究.pdfVIP

学兔兔 2012年第10期 混凝土与水泥制 品 2012 No．10 1O月 CHINA C0NCRETE AND CEMENT PRODUC October 高强再生轻骨料和玻璃微珠配制 轻质高强混凝土的研究 陈雪梅 ，严 云1．2，张 旭 ，胡志华 ， (1．西南科技大学先进建筑材料~t)ll省重点实验室，绵阳621010；2．四川省非金属复合与功能材料 重点实验室一省部共建国家重点实验室培育基地，绵阳621010) 摘 要：采用高强再生轻骨料和玻璃微珠，利用体积法配制出了性能满足预定控制要求的轻质高强混凝土。通 过对比试验研究了玻璃微珠、水泥品种、骨料掺量对轻质高强混凝土力学性能和工作性能的影响。结果表明，调节玻 璃微珠的粒度和掺量可有效控制混凝土的表观密度，使用高强再生轻骨料可提高混凝土的强度和工作性。试验配制 出了表观密度1520kg／m3、28d抗压强度58．9 MPa、比强度1．0667、工作性能较好的轻质高强混凝土。 关键词：再生轻骨料；玻璃微珠；轻质高强混凝土；比强度 Abstract：Based on the volume mix proportion procedure，the high—strength lightweight concrete meeting the control requirements of scheduled performances is prepared by using high-strength recycled lightweisht aggregates and glass microspheres． n1e effects of glass microspheres．cement varieties and content of recycled lightweight aggregates on the mechanical properties and workability of high-strength lightweight concrete are studied by comparison tests．The results show that varying either the particle size or content of glass microspheres can effectively control the surface density of concrete，and using high—strength recycled lightweight aggregates can improve the compressive strength and workability of concrete．At last，the high-strength lightwei t concrete with good workability，compressive strength achieving 58．9 MPa， surface density of 1520kg／m ，and ratio of strength to density of 1．0667 can be obtained． Key words：Recycled lightweight aggregates；Glass microspheres；High-strength lightweight concrete；Ratio of strength to density 中图分类号：TU528．2 文献标识码 A 文章编号：1000—4637(2012)1O一07—04 0 前言