我国南方某复杂硫化铜矿石工艺矿物学研究.pdfVIP

第 4 期 ！ 保 $ % 刷用 4 2015 年 8 月 CONSERVATION AND UTILIZATION OFMINERALRESOURCES Aug. 2015 我国南方某复杂硫化铜矿石工艺矿物学研究+ 王星，王三海 ( 长沙有色冶金设计研究院有限公司，湖南长沙 # 0011 ) 摘要:针对某低品位硫化铜矿进行工艺矿物学研究，结果表明，该铜矿石矿物成分复杂，主要原生硫化铜矿 物为黄铜矿，次生硫化铜矿物为铜蓝和少量辉铜矿、砷黝铜矿，氧化铜矿物为黑铜矿脉石矿物以石英、绿帘 石、石榴石、透辉石、透闪石、绿泥石、绢云母、长石为主。原矿含铜0.55%，铜在原生硫化铜和次生硫化铜矿 物中的分布率分别为42.18%和 36.36%。黄铜矿为细~微细粒不均匀嵌布，粒度集中在0.01 ~0.16 mm 铜蓝嵌布粒度则集中在0 .02 ~0 . 16 mm。由于部分硫化铜矿物常和石英、磁黄铁矿共生，选择合理的磨矿细 度 ，使细粒嵌布的铜矿物充分单体解离是本矿石获得较好选矿指标的关键。 关键词:硫化铜矿;矿物组成细粒嵌布 中图分类号:TD91 文献标识码:B 文章编号$1001 -0076(2015)04 - 0017 - 04 D0 I ：10. 13779/ j . cnki. issn 1001 -0076 .2015 .04 .004 Stud y on Process M in eralo gy o f a C o m plex Sulfide C o pp er O re in South o f C hina W ANGXing ，WANGSanhai ( Changsha Engineering Research Institute Ltd. of Nonferrous Metallurgy，Changsha410011，Hunan， China) Abstract : The process mineralogy of a lowgrade sulfide copper ore was researched in this paper. The results show that mineral compositions of tlie copper ore are complex and chalcopyrite is prima? sulfide copper mineral ，while the secondary sulfide copper minerals are covellite and a spot of chalco- cite and tennantite ，and tenorite is the main oxidized copper mineral. The main gangue quartz ，epidote ，garnet ，diopside ，tremolite ，chlorite ，sericite and feldspar. The grade of copper in raw ore is 0.55% and the distributions of Cu in primary and secondary sulfide copper are 42. 18% and 36. 36% respectively. Chalcopyrite is finely -microfinely uneven diseminated between 0.01 mm and 0. 16 mm ，while chalcocite is between 0. 02 mm and 0.16 mm. As tli