al浓相型仓泵使用说明书.doc

AL型浓相气力输送泵 AL Type Concentration Phase Air Delivery Pump 说 明 书 无锡中冶环保科技有限公司 Wuxi Zhongye Environmental Technology Co., Ltd 一、概述General AL型浓相气力输送泵系列引进瑞典先进技术，该设备适用于输送粉煤灰、水泥、水泥生料、矿粉、粮食等粉状物料。 AL type of concentration phase air delivery pump series products adopted the advanced technology introduced from Feida Company, Sweden and AB Company Australia. It is applicable to deliver powder and granule materials as fly- ash, boiler bottom cinder, limestone powder, cement raw meal, breeze and grain etc. AL型浓相气力输送泵与同类产品及机械输送相比较，具有以下优点： Comparing to the similar products and mechanical conveyors, the AL type concentration phase air delivery pump has following advantages: 1. 灰气比（混合比）高,输灰管长度在200米内可达1:40～50以上。 Higher ratio of ash/air (Mix ratio), it reaches more than 1:40~50 with the ash delivery pipe length less than 200 meters. 2. 工作压力低(一般在0.1～0.2MPa)、流速低。在提高输送效率的同时，有效地减少了管道的磨损, 降低了压缩空气耗量。 Lower working pressure (Usually 0.1~0.2MPa), and lower flow rate. Effectively reduces the abrasion of the pipes and reduces the compressed air consumption with higher delivery efficiency. 3. 自动化程度高,操作简单灵活， 利用PLC控制对整个输送过程实行全自动控制。 High degree of automation, easy and simple for operation. PLC control is used for whole delivery process. 4. 关键部件,如进料阀、泵体、控制元件等寿命长,且按通用规范设计, 互换性、通用性强。料位计、压力变送器、电磁阀等主要元器件都采用进口件。 Key parts, such as material inlet valve, valve body and control elements are of long service lifetime, all are standard design, exchangeable and universal. Important parts and elements as material level gauge, pressure transducer, electric magnetic valve are imported. 5. 输送管路布置灵活，能方便地实行集中、分散、大高度、长距离输送。 Flexible arrangement of the delivery pipe, convenient for centralized /separate/high height/long distance delivery. 6. 由于在密封管道中输送物料, 可严格保证物料品质，使其不受潮、无粉尘污染、不受各种气候条件影响, 有利于生产和环境保护。 The materials are delivered in sealed pipes, so that the quality of the material is ensured, they are protected from moisture, dust pollution, effects of weather condition, there