海底输油管道在悬空与腐蚀联合作用下的剩余寿命预测-中国测试.PDFVIP

第44卷第2期 中国测试 Vol.44 No.2 2018年2月 CHINA MEASUREMENT TEST February袁2018 doi院10.11857/j.issn.1674-5124.2018.02.002 海底输油管道在悬空与腐蚀联合作用下的剩余寿命预测 田 凯 渊中石化胜利石油工程有限公司钻井工艺研究院袁山东 东营 257017冤 摘 要院为解决海底输油气管道在悬空与腐蚀联合作用下的剩余寿命预测问题袁提出一种海底输油管道的强度计算 与寿命预测方法遥 通过悬空管道受力分析求得管壁各项应力袁采用应力集中系数法分析腐蚀缺陷对悬空管道强度的 影响袁根据模拟腐蚀试验得出的管道缺陷发展规律建立管道剩余寿命预测模型袁从而解决输油气管道的剩余寿命预 测问题遥实验结果表明院悬空与腐蚀联合作用对管道强度的影响最强袁悬空缺陷次之袁腐蚀缺陷最弱曰随着服役年限的 增长袁悬空与腐蚀缺陷尺寸逐步变大袁管道强度降低袁最终到达一定年限时管道失效遥 关键词院海底输油管道曰水平悬空曰腐蚀缺陷曰剩余寿命预测 文献标志码院A 文章编号院1674-5124渊2018冤02-0006-05 Residual life prediction of submarine oil pipeline under the combination of suspended and corrosion TIAN Kai 渊Drilling Technology Research Institute袁Shengli Oil Service Corporation of SINOPEC袁 Dongying 257017袁China冤 Abstract: In order to solve the problem of residual life prediction of submarine oil pipeline under the combination of suspended and corrosion袁 a method used for strength calculation and residual life prediction of submarine oil pipeline is proposed. Firstly袁 the stress on the pipe wall is got through the stress analysis of suspended pipeline. Then袁 the method of stress concentration factor is used to analyze the influence of corrosion defect to the strength of the suspended pipeline. At last袁 the residual life prediction model of pipeline is established according to the development law of pipeline defects from corrosion simulation tests and the residual life prediction problem of oil pipeline is solved. Experiment results show that the combined effects of suspension and corrosion