甘肃省体育馆训练馆水电质量策划.docxVIP

目录一、工程概况················································2二、质量目标和要求··········································6三、质量管理组织和职责······································7（一）项目部管理机构·······································8（二）管理职责·············································8四、施工管理依据············································9五、资源需求和配置·········································10（一）人员配合·············································10（二）主要施工机械安排：····································11六、主要施工方法及技术质量策划·····························11七、施工质量检查、验收及相关标准···························34八、应收集的信息及传递要求·································35九、原材料验收、检验·······································36十、工程资料管理策划·······································36十一、QC小组活动策划······································37十二、质量通病的预防措施···································38十三、成品保护措施·········································40一、工程概况本工程为甘肃省体育馆训练馆，位于兰州新区。主体地上一层，东西两侧局部三层，夹层作为办公室、活动室、设备间库房等附属用房。建筑总面积为8812.46㎡。该工程建筑安装工程内容有：冷水系统、热水系统、排水系统、采暖工程、电气工程等，各安装工程内容如下：1、冷水系统本工程给水水源为市政自来水，给水压力为0.35MPa，系统竖向不分区，系统为下行上给式，冷水管采用薄壁不锈钢管，双卡压双密封连接或焊接。管径≤50时采用截止阀，＞50时采用闸阀。2、热水系统本工程热水采用集中太阳能热水系统提供洗浴热水。系统竖向不分区，为上供上回同程式；系统设置热水循环泵，循环泵设在训练馆热水机房内。包厢洗手热水由小型即热式电热水器供给。3、排水系统室内生活污水采用污、废水合流制，室内排水系统采用设单立管排水系统，底层单独排出；出户后的生活污水入室外化粪池处理后，再排入市政排水管网。厨房废水经独立的排水管道，排至室外隔油池处理后排至室外检查井。排水管道采用排水用抗震柔性接口铸铁管及管件，W型接口，特种橡胶圈密封、螺栓紧固。屋面雨水采用内排水系统，训练馆屋面、比赛馆屋面雨水为压力流虹吸式雨水系统，经管道汇合后，排至室外雨水井；室外场地雨水经室外雨水口和雨水管道收集后，排入市政排水管网。雨水管、压力废水管采用钢塑复合管，丝接或卡箍连接。4、消火栓系统本工程室内采用临时高压消防系统，系统组成由一层消防水池及消火栓泵、屋顶消防水箱、增压稳压设备；屋顶设一个试验消火栓。加压泵出水管上设DN65试水阀、压力表，持压泄压阀。室内消火栓系统竖向不分区，栓口压力超0.5MPa的采用减压稳压型消火栓。消火栓系统采用热浸镀锌无缝钢管、卡箍连接，消防立管控制阀采用蝶阀。5、自动喷淋灭火系统本工程采用湿式自动喷水灭火系统，除封闭楼梯间、电缆竖井及管道竖井、电气用房等不宜用水扑救的部位外，其余部分均设喷头保护。无吊顶处采用直立型喷头ZSTZ-15，K=80，有吊顶处采用带装饰吊顶型喷头ZSDZ-15，K=80。自动喷水系统采用热浸镀锌无缝钢管，管径≤70时采用丝扣连接，＞70时采用沟槽式卡箍连接，变径处用异径管零件（丝接时）不能用补芯，异径管径二者相差＞50时采用大小头。6、供暖系统本工程热源由设于比赛馆一层锅炉房内的两台三回路天然气真空热水锅炉分别提供，散热器供暖回路供回水温度为75/50℃低温热水。比赛馆设置空调系统，冬季设置散热器供暖系统，在非使用时间作为值班供暖，采用下供下回双管同程式系统。卫生间、走道、楼梯间及淋浴间等采非空调房间设置散热器供暖系统，采用下供下回双管同程式系统。供回水干管均敷设于一层地沟内，每组散热器设二通或三通自动恒温控制阀，以便于分室控温。散热器选