kp杨木漂白浆课程设计.docVIP

年产30万吨漂白杨木KP浆制浆车间洗筛漂工段设计 第 PAGE 12 页 共 NUMPAGES 33 制浆车间筛选漂白工段工艺流程设计说明书 年产30万吨漂白杨木KP浆制浆车间洗筛漂工段工艺流程设计 摘要 杨木KP浆蒸煮后经DD洗浆机洗涤，先进入一段木聚糖酶的处理，然后进行中浓氧脱木素段,在氧脱木素前经过能较好地提高氧脱木素段的选择性和有效性的过氧酸预处理。氧脱出来后经除节筛，两段压力筛筛选、净化后进入D/Ep/P三段轻ECF漂白。，最终白度可达 90% 以上。出来的漂白浆可以直接成商品浆售出或送造纸车间抄纸。木聚糖酶可以降低杨木浆的卡伯值， 杨木KP 浆经氧脱木素, 卡伯值降低48. 1%。杨木浆在氧脱木素前用过氧酸预处理,脱木素程度分别达55. 8%.氧化氯作为一种广谱、高效、无毒的消毒剂，本身性能柔和，不损伤纤维，漂白后的纸浆白度高，纸浆得率高。过氧氢强化的碱抽提中过氧化氢的使用可以使纸张白度显著提高。另一个明显的效果是，过氧化氢可以漂白浆料中的碎片。终段漂白采用H2O2漂白可改善浆料白度的稳定性。 关键词：杨木KP浆；洗筛漂；DD洗浆机；氧脱木素；两段压力筛；二氧化氯漂白；ECF漂白 An annual output of 300,000 tons of bleached pulp pulp plant poplar KP wash sieve drift section process design Abstract Poplar KP pulp after cooking by DD washed pulp washing machine, first into the processing section of xylanase, and then the medium consistency oxygen delignification, after oxygen delignification can better improve the oxygen delignificationthe selectivity and effectiveness of the peroxy acid pretreatment. Knotter sieve out the oxygen off, two-stage pressure sieve screening purified into D / Ep / P three sections of light ECF bleaching. Final whiteness of up to 90%. The bleached pulp out directly into market pulp sold or send papermaking workshop papermaking. Xylanase can reduce Young Kappa number of the pulp, poplar KP slurry through oxygen delignification, the kappa number 48.1% reduction. Yang wood pulp before oxygen delignification with peracetic acid pretreatment, delignification 55.8%, respectively. Chlorine monoxide as a broad-spectrum, efficient, non-toxic disinfectant itself gentle performance, without damaging the fibers whiteness bleached pulp, the pulp is high. The use of hydrogen peroxide can be enhanced alkali extraction hydro peroxide whiteness improved significantly. Another significant effect is that the hydrogen peroxide can not be bleached in the slurry debris. End-stage bleaching with H2O2 bleached pulp brightness stability can be improved. Key words: Poplar KP pulp; Wash sieve drift; DD washer; Oxygen deli