低温煤器和暖风器联合系统参数优化.PDFVIP

第47 卷 第3 期 热 力 发 电 Vol.47 No.3 2018 年 3 月 THERMAL POWER GENERATION Mar. 2018 低温省煤器与暖风器联合系统参数优化 张知翔，徐党旗，邹小刚，李 楠，车宏伟，薛 宁 （西安热工研究院有限公司，陕西 西安 710054） ［摘 要］介绍了国内低温省煤器与暖风器联合系统的研究现状，以山东某660 MW 机组为例，计算 了低温省煤器换热面积及暖风器出口风温对整个系统节煤量、静态投资及静态投资回收期 的影响。结果表明：低温省煤器换热面积越大，系统节煤量越大，投资越大，系统静态投 资回收期随着低温省煤器换热面积增大先降低后升高；暖风器出口风温越高，系统节煤量 越大，投资越大，系统静态投资回收期随暖风器出口风温的提高先降低后升高。推荐该机 组低温省煤器纵向为40 排，暖风器出口风温65~75 ℃。 ［关 键 词］低温省煤器；暖风器；联合系统；换热面积；出口风温；节煤量；经济性 ［中图分类号］TK223 ［文献标识码］A ［DOI 编号］10.19666/j.rlfd.201707131 ［引用本文格式］张知翔, 徐党旗, 邹小刚, 等. 低温省煤器与暖风器联合系统参数优化[J]. 热力发电, 2018, 47(3): 94-98. ZHANG Zhixiang, XU Dangqi, ZOU Xiaogang, et al. Parameter optimization for combined system of low pressure economizer and air heater[J]. Thermal Power Generation, 2018, 47(3): 94-98. Parameter optimization for combined system of low pressure economizer and air heater ZHANG Zhixiang, XU Dangqi, ZOU Xiaogang, LI Nan, CHE Hongwei, XUE Ning (Xi’an Thermal Power Research Institute Co., Ltd., Xi’an 710054, China) Abstract: The research status of the combined system of low pressure economizer and air heater was introduced. By taking a 660 MW unit in Shandong Province as the example, the influence of heat exchange area of low pressure economizer and outlet air temperature of air heater on energy conservation potential, static investment and static payback period of the whole system was calculated. The result shows that, the larger the heat exchange area of low pressure economizer, the greater the energy conservation potential and static investment. The static payback period of the system decreas