操作条件及运行通量对超滤膜污染影响.pdf

网络出版时间：2014-06-10 09:38 网络出版地址：/kcms/detail/37.1440.N0938.009.html 操作条件及运行通量对超滤膜污染的影响 1 2，＊ 1 1 1 何 青 ，李圭白 ，吕 谋 ，孟 聪 ，陈 超 (1.青岛理工大学 环境与市政工程学院，青岛 266033 ；2.哈尔滨工业大学 市政环境工程学院，哈尔滨 150001） 摘 要：从优化操作工艺和摸索长期运行零污染通量2 个角度对浸没式超滤膜污染进行了研 究。结果表明：曝气强度为40 m 3 (m2 h) 时，对膜污染的去除可取得良好的效果；运行 周期越短，膜污染越轻；存在一个通量范围，在此范围内，TMP 和膜阻力随时间增长缓慢， 一旦超出了这个范围，TMP 和膜阻力便会随时间增长迅速增加。 关键词：超滤膜；运行条件；长期运行；通量；膜污染 中图分类号：TU991.2 文献标志码：A 文章编号：1673-4602 （2014 ）03-0000-00 Influence of different operating conditions and fluxes to membrane fouling 1 2,* 1 1 1 HE Qing ，LI Gui-bai ，LÜ Mou ，MENG Cong ，CHEN Chao (1. School of Environmental and Municipal Engineering, Qingdao Technological University, Qingdao 266033, China; 2. Institute of Environmental and Municipal Engineering, Harbin Institute of Technology, Harbin 150001, China) Abstract: The paper has an experience of ultrafiltration membrane at different operating conditions and different fluxes, which aims at having a studying on the ultrafiltration fouling. It shows that the 40 m3/(m2•h) gas intensity plays a very good effect on membrane fouling removal. The shorter the selected operating cycle is, the lighter the membrane fouling will be. And there is a range of flux. Under the flux, transmembrane pressure will increase very slowly. But if