纤维增强泡沫混凝土性能试验研究.pdfVIP

学兔兔 第 13卷第3期 建 筑 材 料 学 报 VoI_13。No．3 2010年 6月 J0URNAL OF BUILDING MATERIALS Jun．，2010 文章编号：1007-9629(2010)03—0286—06 纤维增强泡沫混凝土性能试验研究 陈 兵， 刘 睫 (上海交通大学 土木系，上海 200240) 摘要：以普通硅酸盐水泥为结合剂，用粉煤灰和微硅粉取代砂和部分水泥制备泡沫混凝土．探讨了 微硅粉和聚丙烯纤维对表观密度为800～1 500 kg／m。的泡沫混凝土抗压强度、劈裂抗拉强度、收 缩率的影响．结果表明：采用掺加微硅粉和聚丙烯纤维技术，可以制备出表观密度在800～1 500 kg／m。，抗压强度达到1O～50 MPa的高强泡沫混凝土；微硅粉和聚丙烯纤维能显著提高泡沫混凝 土的抗压强度，且泡沫掺量越大，其增强效果越显著；掺入聚丙烯纤维后，泡沫混凝土的劈裂抗拉强 度显著提高，干缩率明显下降． 关键词：泡沫混凝土；微硅粉；聚丙烯纤维；抗压强度；劈裂抗拉强度 中图分类号：TU528．2 文献标志码：A doi：10．3969／j．issn．1007—9629．2010．03．003 Experimental Research on Properties of Foamed Concrete Reinforced with POlypr0pylene Fibers CHEN Bing。 L 己，Jie (Department of Civil Engineering，Shanghai Jiaotong University，Shanghai 200240，China) Abstract：Silica fume and fly ash were used to replace part of cement and all sand to produce foamed con— crete．The effects of silica fume and polypr0pylene(PP)fiber on the compressive and splitting tensile strength，and drying shrinkage of foamed concrete with density of 800—1 500 kg／m。were investigated． The results indicate that foamed concrete with density of 800—1 500 kg／m。and compressive strength of 10 — 50 MPa can be made by using silica fume and PP fiber．Silica fume and PP fiber greatly improve the eom— pressive strength of foamed concrete，and the higher the use level of foam，the higher the compressive strength．In addition，adding PP fiber significantly improves the splitting tensile strength and drying shrinkage resistance． Key words：foamed concrete；silica fume；polypropylene(PP)fib