长春某白酒厂污处理工艺.docVIP

长春工业大学学士学位论文 分类号：X131.2 单位代码：10190 学号 密级：无 学士学位论文 长春某白酒厂 Changchun a winery 800m3/d污水处理工艺设计 800m3 / d sewage treatment process design 学生姓名： 车田正美 专 业： 环境工程 指导教师姓名： 贾诩 指导教师职称： 讲师 2017年6月 PAGE \* MERGEFORMAT 1 PAGE \* MERGEFORMAT 1 中文摘要 白酒工业在我国迅猛发展的同时，排出了大量的白酒废水，对环境的影响十分重大。本设计针对白酒废水，设计一套符合国标的白酒废水处理工艺，设计程度为初步设计。 白酒废水属高浓度有机废水，其特点是：高，低，色度较高，间断排放，负荷波动较大，不经处理会严重污染环境。 该白酒废水处理厂的处理水量为，初始浓度为,为，为。废水中的污染物属第Ⅱ类污染物。根据废水性质，本设计采用了“”工艺，整个处理系统耐冲击负荷能力强。整个设计采用物化和生化相结合的工艺，不投药，最大限度地减少污泥产生量。处理后的浓度为，为，为，出水水质符合《发酵酒精和白酒工业水污染物排放标准》类水域一级标准。整个设计可靠性好，耐负荷冲击能力强，投资省，占地少，运行能耗低。废水处理采用的技术先进可靠，技术经济合理，社会环境效益显著。 关键词：白酒废水 处理工艺 水解酸化 IC CASS Abstract Liquor industry in Chinas rapid development at the same time, discharged a lot of liquor wastewater, caused a great threat to the environment. The design for the liquor wastewater, the design of a set of national standard liquor wastewater treatment process, the design level for the initial design. Liquor wastewater is a high concentration of organic wastewater, which is characterized by: high, low , high color, intermittent emissions, load fluctuations, without treatment will seriously pollute the environment. The treated water of the liquor wastewater treatment plant is , the initial concentration is , is , is .. Pollutants in waste water are Class II contaminants. According to the nature of wastewater, this design uses a hydrolysis acidification process, the entire processing system impact load capacity. The whole design uses a combination of materialized and biochemical processes, without administration, to minimize the amount of sludge generated. After treatment, the concentration was , was , was , and the effluent quality accorded with water level standard of Fermented Alcohol and Liquor Industry Water Pollutant Discharge Standard.