公路施工来料沥青质量监管快检新技术及其应用.pdfVIP

公路施工来料沥青质量监管快检新技术及其应用 1 1 1 2 3 4 5 张文宇 胡爱琴 忻欣 赵蔚 刘开琼 李喆 李佩 (1.西派特（北京）科技有限公司，北京100029；2 交通运输部科学研究院, 北京100013; 3 苏交科集团股份有限公司道路养护 中心 ,江苏 南京 210019; 4 内蒙古自治区交通建设工程质量监督局；5 北京市政工程研究院；6 山东京博石油化工有限公司) 地址：北京市朝阳区北辰东路8 号院16 号楼605 电话：010 E-mail：marketing@ 摘要:传统的沥青测试方法因大量耗时而无法用于高速公路沥青质量检测中.基于ATR-FTIR 和化学计量学设计的一款快速分析仪可以在5min 以内分析沥青的多种性质,可以快速的分 辨标准样品与待测样品的一致性,同时建立了针入度和软化点的校正模型.仪器和模型已经 成功的在荣乌高速公路使用,结果显示新技术快速、智能，适合于高速公路的快速检测。 关键词：高速公路、沥青快速分析仪、沥青性质、模型 New technology and application of asphalt quality supervision for highway construction Zhang Wen-yu 1 1 1 2 3 4 5 ,Hu Aiqin ,Xin Xin ,Zhao Wei ,Liu Kaiqiong Li Ji ,Li Pei (1. CSEPAT(Beijing) Technology CO., LTD. Beijing,100029 ；2. Scientific research institute of the Ministry of transport,Beijing, 100013;3. Jiangsu Transportation Institute,Nanjing, 210019 4.The Inner Mongolia Autonomous Region Traffic Construction Project Quality Supervision Bureau 5.Beijing Municipal Engineering Research Institute 6.Shandong Jingbo Petrochemical Co., Ltd.） Abstract:Conventional asphalts analytical methods are too time-consuming to be used in asphalt quality supervision for highway construction. Based on principle of attenuated Total Reflection FT-IR and chemometrics, a new portable analyzer was developed for rapid determination of multi-properties of asphalts in less than 5 min. The analyzer can be used to carry rapid consistency testing between samples under test and standard samples. Quantitative calibration models of penetration index and softening point index of asphalts were established. The analyzer and models have been successfully applied in Rong-Wu highway construction. The results show that the new technology is rapid, intelligent and easy to use in situ and suitable for asphalt q