苯丙乳胶漆的制备工艺与性能研究.docxVIP

苯丙乳胶漆的制备工艺与性能研究 苯丙乳胶漆的制备工艺与性能研究 第40卷第9期2021年9月 应用化工Vol．40No．9Sep．2021 Applied Chemical Industry 苯丙乳胶漆的制备工艺与性能研究 鄢瑛，梅燕，张会平 （华南理工大学化学与化工学院，广东广州510640） 摘要：采用不同晶型、种类、粒径的颜填料，系统考察了乳胶漆颜料浆液细度随时间或搅拌转速的变化规律，优化 了苯丙乳胶漆的配伍工艺。结果表明，在相同分散时间内，金红石钛白粉作颜料的浆液细度比锐钛矿型钛白粉颜滑石粉、硅藻土和蒙脱石粉作填料时颜料浆液细度料浆液细度小；煅烧高岭土作填料的浆液细度比分别以重钙、 小；浆液细度均随分散时间和搅拌转速的增加而减小，随填料粒径的减小而减小；以金红石型钛白粉和1250目煅烧高岭土，搅拌转速为1500r /min时制备出的乳胶漆颜料浆液细度在分散时间为15min 时为45μm ，胶粒粒径主要分布在1 10μm 的范围内，粘度稳定性较好。关键词：乳胶漆；乳液；颜料；填料 中图分类号：TQ 630．67 文献标识码：A 文章编号：1671－3206（2021）09－1500－05 Preparation and properties of styrene-acrylic emulsion paint YAN Ying ，MEI Yan ，ZHANG Hui-ping （School of Chemistry and Chemical Engineering ，South China University of Technology ，Guangzhou 510640，China ） Abstract ：The effects of dispersion time and stirring speed on the fineness of emulsion paint pigment slur-ry by adding pigments with different crystals and five fillers with different particle sizes were investigated ，respectively．The experimental results showed that fineness of emulsion paint pigment slurry with rutile TiO 2was smaller than that with anatase TiO 2．The fineness of emulsion paint pigment slurry with calcined kaolin was smaller than that with heavy calcium ，talc ，diatomite and montmorillonite powder in the same respectively．The fineness of emulsion paint pigment slurry reduced with increasing the dispersion time ， dispersion time and stirring speed ，as well as decreasing the particle size of fillers．The emulsion paint was prepared with fineness of 45μm at the dispersion time of 15min ，particle size distribution of 1 10μm and high viscosity stability by using rutile TiO 2and calcined kaolin with the particle size of 1250mesh at the stirring speed of 1500r /min． Key words ：emulsion paint ；emulsion ；pigment ；filler 随着社会经济的发展，人们对涂料的使用要求这也极大的促进了以乳胶漆为代表的水越来越高， 性环保建筑涂料的进步 积浓度比和乳液粒径对乳胶漆颜料分布的影响。Jarnstrom 等［13］考察了乳液对乳胶漆的表面结构和颜料润湿的影响。吕少华等定性影响。曾羽燕等 。在乳胶漆颜、填料分散阐述了乳胶漆稳定 过程中，细度作为生产工