(8277)--硫酸盐环境下CFRP加固顺序对混凝土梁界面黏结性能影响.pdfVIP

硫酸盐环境下CFRP 加固顺序对混凝土梁 界面黏结性能影响 摘 要： 提出了先粘贴 CFRP 后硫酸盐腐蚀以及先硫酸盐腐蚀后粘贴 CFRP 两种加固顺序， 开展了 64 块 CFRP-混凝土试件的双剪试验，分析了CFRP 粘贴顺序、粘贴长度、粘贴宽度对混凝土界面破坏模态、抗压强度、剥 离荷载、黏结强度、界面能、黏结应力-滑移曲线的影响，并基于硫酸盐环境影响系数建立了CFRP-混凝土界面黏结 强度模型。 试验结果表明，硫酸盐环境下，环氧树脂胶体能较好的保护混凝土黏结区域；随着硫酸盐腐蚀时间的延 长，界面的剥离荷载、黏结强度均呈下降趋势，腐蚀至 123 d 时，下降最为严重，而对于界面断裂能，腐蚀至 123 d 时， 下降幅度反而降低；CFRP 黏结长度为65 mm 下的界面黏结强度最大，随着黏结长度的增加，CFRP-混凝土界面的 黏结性能逐渐降低；硫酸盐环境影响系数的提出可为恶劣环境的分类提供科学依据。 关键词：混凝土；CFRP ；双剪试验；硫酸盐；界面；环境影响系数 中图分类号： 文献标识码： ： TU528.01 A doi 10.19761/j.1000-4637.2020.01.041.07 Influence of CFRP Paste Sequence on Bond Performance of Concrete Beam Interface under Sulfate Environment Zhan-yin1 FU Ming-chun2 WANG , （1.Qinghai Communication Technical College, Xining 810003; 2.Beijing University of Science and Technology Department of Civil and Environmental Institute, 100192 ） Abstract: Two kinds of reinforcement sequence, CFRP first, then sulfate corrosion, and sulfate first, then CFRP, were put forward, and the double shear tests of 64 CFRP-concrete specimens were carried out, and the effects of CFRP paste sequence, bond length and width of bond on the failure mode, compressive strength, failure load, bond strength, fracture energy, bond stress- slip curve were analyzed, the bond strength model of CFRP-concrete interface was established based on the environmental impact coefficient of sulfate. The results show that the sulfate environment, epoxide resin can better protect concrete bond area. With the prolongation of sulfate corrosion time, failure