大容量锅炉屏式过热器利用系数的研究.pdfVIP

30 5 动 力 工 程 学 报 Vol. 30 No. 5 2010 5 Journal of Chinese Society of Pow er Engineering M ay 2010 : 1674-7607 2010 05-0313-06 :TK223 :A :470. 30 周 托, 张忠孝, 乌晓江, 谢 浩, 姚志鹏, 赵 超 , 2000 3 : 采用三维数值计算方法, 1 台660 MW 超超临界0 型锅炉分隔屏和后屏过热器在5 种 负荷工况下的传热情况进行了模拟, 并结合锅炉热力计算标准方法 两类屏式过热器的利用系数 进行了修正. 结果表明: 炉膛火焰辐射及烟气 管屏的不均匀冲刷导致了管屏壁面传热不均匀; 锅 炉负荷变化 屏式过热器利用系数的影响很大, 在5 种负荷工况下, 两类屏式过热器的利用系数均 随着锅炉负荷的提高而增大. : 大容量锅炉; 屏式过热器; 利用系数; 热力计算; 数值计算 St udy on Ut ilizat ion Factor of Platen Superheater of Large Capacity Boilers ZH O U T uo , ZH A N G Zhong-x iao , W U X iao-j iang , X I E H ao , YA O Zhi-p eng , ZH A O Chao School of Energy and Pow er Engineering, University of Shanghai for Science and Technology, Shanghai 2000 3, China Abstract: T hree-dimensional numerical calculation method w as adopted to simulate the heat transfer cond-i tions in division platen and rear platen superheaters of a 660 MW ultra supercritical boiler under five differ- ent loads. Referring to the thermal calculation standard method of boiler, the utilization factors of the tw o kinds of platen superheaters w ere modified. Results show that the furnace flame radiation and uneven sw eep of the flue gases to the pipes result in nonuniform heat transfer of platen superheater w alls. The boiler load variation has great effect on the utilization factor of the platen superheaters, and the utilization factors of the tw o kinds of the platen superheaters increase w ith raising the boiler load under five different loads. Key words: large capacity boiler; platen superheater; utilization factor; thermal calculation; numerical ca-l culation