响应面法优化超声波环境中壳聚糖的降解性研究毕业设计论文.docVIP

2013届本科毕业论文 论文题目 响应面法优化超声波环境中壳聚糖 降解性的研究 学生姓名： **** 所在系别： ******** 所学专业： *********** 导师姓名： ****** 完成时间： 2013年5月 摘要： 应用超声波辐射分别研究了甲壳素在水中和乙醇介质中脱乙酰反应，及在超声波环境中超声波对壳聚糖在乙酸溶液中降解的强化作用，并将其与无超声波辐射下甲壳素的脱乙酰反应进行了对比，结果表明：在水中和乙醇2种介质中超声波可以促进反应，在较低温度（45℃）的反应温度下即可提高产品脱乙酰度和粘度，超声波对水介质中的脱乙酰反应作用比在乙醇中更加显著，在水中反应6h，脱乙酰度可高达 98. 2% 。通过响应面法研究了超声波作用温度，作用强度，作用频率和作用时间等4因素对壳聚糖溶解性的显著影响。在4个影响壳聚糖降解的超声作用因素中，影响度最大的是超声作用强度，其次为作用频率、作用温度和作用时间。经响应面法处理数据，得出在超声波环境中壳聚糖溶解性的最佳的作用系数为：最佳作用温度为56.25℃，最佳作用功率为97.43W，最佳作用频率为19.81KHZ，最佳作用时间为53.75min。 关键词：超声波，壳聚糖，乙醇，脱乙酰度，粘度 Response Surface Method To Optimize The Ultrasonic Environment in The process Of Solubility Of Chitosan ******* Abstract The ultrasonic radiation were applied to investigating deacetylation of chitin in the medium of water and ethanol, and the ultrasonic wave in the ultrasonic environment degradation of chitosan in acetic acid solution strengthening effect,(and the degradation strengthening function of the ultrasonic wave in ultrasinic environment to the chitosan in the acetic acid And then compared with the ultrasonic radiation chitin deacetylationthe reaction were , results show that: the ultrasonic waves can promote the reaction medium in water and ethanol, so improving the degree of deacetylation and a viscosity in the lower temperature (45℃) reaction temperature, but the reaction effect in the ultrasonic off the aqueous mediumacetylation is more obvious than in ethanol, 6h reaction in water, up to 98.2% degree of deacetylation. With the help of the response surface method,the writer have researched the temperature ,intensity,rate and time of the ultrasonic and what influence they have for chitosan solubeness.The four chitosan degradation ultrasound factors, the maximum degree of influence of ultrasonic intensity, followed by the role of frequency, the role of temperature and time. Response surface methodology process the data obtained in the ultrasonic environment chitosan solubility coefficient of action: the best role of temperature is 56.2